JBL ON STAGE III IIIP (serv.man2) EMC - CB Certificate ▷ View online
<12014238 001 >
Page 40 of 77
TRF No.:IECEN60950_1B
TRF originator: SGS Fimko
Storage Cap.
(C2)
(C2)
Various
Various
4.7-47µF;
Min. 400VDC; 105°C
Min. 400VDC; 105°C
--
--
Euro-plug
Dee Van
Enterprise Co.,
Ltd.
Enterprise Co.,
Ltd.
DVE
2.5A; 250VAC
EN 50075
TÜV
Rheinland
(J 2156136)
Rheinland
(J 2156136)
BS plug
Dee Van
Enterprise Co.,
Ltd.
Enterprise Co.,
Ltd.
DVE-UK
0.7A; 250VAC
BS 1363
Tested with
appliance
appliance
Insulation
material of BS
plug holder
material of BS
plug holder
GE Plastics Co.,
Ltd.
Ltd.
SE1X
PPE+PS; V-1; 105°C;
thickness: min. 0.8mm
thickness: min. 0.8mm
--
UL
Insulation
material of
Australian plug
material of
Australian plug
Dupont
FR50
PA66, 130°C, V-0
--
UL
Enclosure
GE Plastics Co.,
Ltd.
Ltd.
SE1X
PPE+PS; V-1;
105°C; thickness: min.
2.0mm
105°C; thickness: min.
2.0mm
--
UL
Insulation tape
Four Pillars
35660Y/MY130 130°C
--
UL
Primary lead
wire
wire
Various
1007
105°C; min. 24AWG;
VW-1; 300V
VW-1; 300V
--
UL
Output cord
Various
Various
80°C; min. 22AWG;
VW-1
VW-1
--
UL
Output cord (if
the part in
enclosure
covered with
heat shrinkable
tube)
the part in
enclosure
covered with
heat shrinkable
tube)
Various
Various
60°C; min. 22AWG;
VW-1
VW-1
--
UL
Heat shrinkable
tube
tube
Various
Various
125°C; 600V; VW-1
--
UL
PCB
Various
Various
V-0 or better;
min. 130°C
min. 130°C
--
UL
Note(s):
An asterisk indicates a mark that assures the agreed level of surveillance.
1.6.2
TABLE: electrical data (in normal conditions)
P
Fuse # Irated (mA)
U (V)
P (W)
I (mA)
Ifuse (mA) Condition/status
Model DSA-20R-12 FEU 090180
F1
--
90
22.5
421
421
Rated load at 50 Hz
F1
--
90
22.3
434
434
Rated load at 60 Hz
F1
700
100
22.1
371
371
Rated load at 50 Hz
F1
700
100
22.1
402
402
Rated load at 60 Hz
F1
700
240
22.1
226
226
Rated load at 50 Hz
F1
700
240
22.0
213
213
Rated load at 60 Hz
<12014238 001 >
Page 41 of 77
TRF No.:IECEN60950_1B
TRF originator: SGS Fimko
F1
--
264
22.2
218
218
Rated load at 50 Hz
F1
--
264
22.2
207
207
Rated load at 60 Hz
Model DSA-20R-12 FEU 102204
F1
--
90
25.3
476
476
Rated load at 50 Hz
F1
--
90
25.3
484
484
Rated load at 60 Hz
F1
700
100
24.9
417
417
Rated load at 50 Hz
F1
700
100
25.0
447
447
Rated load at 60 Hz
F1
700
240
24.6
246
246
Rated load at 50 Hz
F1
700
240
24.6
234
234
Rated load at 60 Hz
F1
--
264
25.1
238
238
Rated load at 50 Hz
F1
--
264
24.9
228
228
Rated load at 60 Hz
Model DSA-20R-12 FEU 150204
F1
--
90
24.6
459
459
Rated load at 50 Hz
F1
--
90
24.6
470
470
Rated load at 60 Hz
F1
700
100
24.3
409
409
Rated load at 50 Hz
F1
700
100
24.3
433
433
Rated load at 60 Hz
F1
700
240
24.3
244
244
Rated load at 50 Hz
F1
700
240
24.3
230
230
Rated load at 60 Hz
F1
--
264
24.7
234
234
Rated load at 50 Hz
F1
--
264
24.5
224
224
Rated load at 60 Hz
Note(s):--
2.1.1.5
TABLE: max. V, A, VA test
P
Voltage (rated)
(V)
Current (rated)
(A)
Voltage (max.)
(V)
Current (max.)
(A)
VA (max.)
(VA)
Model DSA-20R-12 FEU 150204
15.0
1.36
14.9
2.52
26.2
Model DSA-20R-12 FEU 102204
10.2
2.00
10.2
2.98
22.8
Note(s):
Test voltage:
240 V
Test frequency: 60 Hz
2.1.1.7
TABLE: discharge test
N/A
Condition
τ
calculated
(s)
τ
measured
(s)
t u→ 0V
(s)
Comments
<12014238 001 >
Page 42 of 77
TRF No.:IECEN60950_1B
TRF originator: SGS Fimko
Note(s): --
2.2.2
TABLE: Hazardous voltage measurement
P
max. Voltage
Transformer
Location
V peak
V d.c.
Voltage Limitation
Component
Component
Model DSA-20R-12 FEU 150204
T1
8-10
34.8
--
D9
Output
--
14.9
Note(s):
Test voltage:240 V
Test frequency: 60 Hz
The limits of SELV were not exceeded between any two points of the secondary circuit.
2.2.3
TABLE: SEL voltage measurement
P
Location
Voltage measured (V)
Comments
Model DSA-20R-12 FEU 150204
Output
0
Short-circuit D9, circuit protected immediately.
Note(s): --
2.4.2
TABLE: limited current circuit measurement
N/A
Location
Voltage
(V)
Current
(mA)
Freq.
(kHz)
(kHz)
Limit
(mA)
Comments
Note(s):
Test voltage:
--
Test frequency: --
2.5
TABLE: limited power source measurement
P
Limits
Measured
Verdict
Model DSA-20R-12 FEU 150204
Uoc = 14.9 V (measured under no load conditions)
According to Table 2B (normal condition)
current (in A)
≤8
2.52
P
apparent power (in VA)
≤5*Uoc= 74.5
26.2
P
According to Table 2B (Opto-coupler primary open-circuited)
<12014238 001 >
Page 43 of 77
TRF No.:IECEN60950_1B
TRF originator: SGS Fimko
current (in A)
≤8
2.53
P
apparent power (in VA)
≤5*Uoc= 74.5
26.8
P
According to Table 2B (Opto-coupler primary short-circuited)
current (in A)
≤8
0 (unit shut down)
P
apparent power (in VA)
≤5*Uoc= 74.5
0 (unit shut down)
P
According to Table 2B (Opto-coupler secondary open-circuited)
current (in A)
≤8
2.50
P
apparent power (in VA)
≤5*Uoc= 74.5
27.1
P
According to Table 2B (Opto-coupler secondary short-circuited)
current (in A)
≤8
2.80
P
apparent power (in VA)
≤5*Uoc= 74.5
28.1
P
Model DSA-20R-12 FEU 090180
Uoc = 9.0 V (measured under no load conditions)
According to Table 2B (normal condition)
current (in A)
≤8
3.13
P
power (in VA)
≤5*Uoc=45.0
22.5
P
According to Table 2B (Opto-coupler primary open-circuited)
current (in A)
≤8
2.94
P
power (in VA)
≤5*Uoc=45.0
27.6
P
According to Table 2B (Opto-coupler primary short-circuited)
current (in A)
≤8
0 (unit shut down)
P
power (in VA)
≤5*Uoc=45.0
0 (unit shut down)
P
According to Table 2B (Opto-coupler secondary open-circuited)
current (in A)
≤8
3.12
P
power (in VA)
≤5*Uoc=45.0
26.3
P
According to Table 2B (Opto-coupler secondary short-circuited)
current (in A)
≤8
3.07
P
power (in VA)
≤5*Uoc=45.0
29.3
P
Note(s): --
2.6.3.3
TABLE: ground continue test
N/A
Location
Resistance measured (mΩ) Comments
Note(s): --
Click on the first or last page to see other ON STAGE III IIIP (serv.man2) service manuals if exist.