Sony DSC-R1 (serv.man2) Service Manual ▷ View online
4-5
DSC-R1_L2
4-2. SCHEMATIC DIAGRAMS
4-2. SCHEMATIC DIAGRAMS
4-2. SCHEMATIC DIAGRAMS
1. Connection
2. Adjust the distance so that the output waveform of
Fig. a and the Fig. b can be obtain.
When indicating parts by reference number, please
include the board name.
include the board name.
(For schematic diagrams)
• All capacitors are in
• All capacitors are in
µ
F unless otherwise noted. pF :
µ
µ
F. 50 V or less are not indicated except for electrolytics
and tantalums.
• Chip resistors are 1/10 W unless otherwise noted.
k
Ω
=1000
Ω
, M
Ω
=1000 k
Ω
.
• Caution when replacing chip parts.
New parts must be attached after removal of chip.
Be careful not to heat the minus side of tantalum
capacitor, Because it is damaged by the heat.
Be careful not to heat the minus side of tantalum
capacitor, Because it is damaged by the heat.
• Some chip part will be indicated as follows.
Example
C541
L452
22U
10UH
TA A
2520
• Constants of resistors, capacitors, ICs and etc with XX
indicate that they are not used.
In such cases, the unused circuits may be indicated.
In such cases, the unused circuits may be indicated.
• Parts with
★
differ according to the model/destination.
Refer to the mount table for each function.
• All variable and adjustable resistors have characteristic
curve B, unless otherwise noted.
• Signal name
XEDIT
→
EDIT
PB/XREC
→
PB/REC
•
2
: non flammable resistor
•
5
: fusible resistor
•
C
: panel designation
•
A
: B+ Line
•
B
: B– Line
•
J
: IN/OUT direction of (+,–) B LINE.
•
C
: adjustment for repair.
•
A
: not use circuit
• Circled numbers refer to waveforms.
(Measuring conditions voltage and waveform)
(Measuring conditions voltage and waveform)
• Voltages and waveforms are measured between the
measurement points and ground when camera shoots
color bar chart of pattern box. They are reference values
and reference waveforms.
(VOM of DC 10 M
color bar chart of pattern box. They are reference values
and reference waveforms.
(VOM of DC 10 M
Ω
input impedance is used)
• Voltage values change depending upon input
impedance of VOM used.)
Kinds of capacitor
Case size
External dimensions (mm)
Y
ellow
A
A
B
B
A=B
Fig. a (Video output terminal output waveform)
H
Cyan
Green
White
Magenta
Red
Blue
Fig.b (Picture on monitor TV)
CRT picture frame
Electronic beam
scanning frame
scanning frame
THIS NOTE IS COMMON FOR SCHEMATIC DIAGRAMS
(In addition to this, the necessary note is printed in each block)
(In addition to this, the necessary note is printed in each block)
Pattern box
Pattern box PTB-450
J-6082-200-A
or
Small pattern box
PTB-1450
J-6082-557-A
J-6082-200-A
or
Small pattern box
PTB-1450
J-6082-557-A
Color bar chart
For PTB-450:
J-6020-250-A
J-6020-250-A
For PTB-1450:
J-6082-559-A
J-6082-559-A
Pattern box
Front of the lens
L = About 90 cm (TELE end) (PTB-450)
L = About 35 cm (TELE end) (PTB-1450)
L = About 35 cm (TELE end) (PTB-1450)
L
Camera
Precautions for Replacement of Imager
• If the imager has been replaced, carry out all the adjustments
for the camera section.
• As the imager may be damaged by static electricity from
its structure, handle it carefully like for the MOS IC.
In addition, ensure that the receiver is not covered with
dusts nor exposed to strong light.
In addition, ensure that the receiver is not covered with
dusts nor exposed to strong light.
The components identified by mark
0
or dotted line with
mark
0
are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0
sont
critiques pour la sécurité.
Ne les remplacer que par une pièce portant le numéro
spécifie.
Ne les remplacer que par une pièce portant le numéro
spécifie.
DSC-R1_L2
TH501
XX
NO MARK:REC/PB MODE
3
4.7
2.6
2.6
0
4.9
0
4.9
0
2.6
0
4.9
0
0
3
4.7
1.1
2.6
2
4
1
5
3
6
7
2.6
Note: IC501 (CMOS imager) and CD-588 complete board are not supplied,
but they are included in CMOS block assy (service assy).
Note: Voltages and Waveforms of IC501 can not be measured, because
this is mounted by the side of the lens.
Note: Take care when you replace the parts because bonding melts
by heating and pressurizing.
0.1u
C510
0.1u
C515
100k
R514
IC501
IMX014AQF-13
1
DVSS1
2
DVDDIO1
3
CKIN
4
DVDD1
5
VRL1
6
VRH1
7
SVSS1
8
SVDD1
9
VREF1
10
HD
11
FD
12
TEST1
13
TEST2
14
TEST3
15
DVDD2
16
DVDDIO2
17
TEST4
18
DVSS2
19
VUSB1
20
AV
S
S
1
21
A
VDD1
22
REFOUT1(B)
23
DRVOUT1
24
OVDD1
25
REFOUT2(R)
26
DRVOUT2
27
OVSS1
28
VREF2
29
SVSS2
30
SVDD2
31
SVDD3
32
SVSS3
33
VREF3
34
OVSS2
35
DRVOUT3(Gb)
36
REFOUT3
37
OVDD2
38
DRVOUT4(Gr)
39
REFOUT4
40
AV
DD2
41
AV
SS2
42
VSUB2
43
DVSS3
44
TEST5
45
DVDDIO3
46
DVDD3
47
SDI
48
SCK
49
SDO
50
XCE
51
XCLR
52
VREF4
53
SVDD4
54
SVSS4
55
VRH2
56
VRL2
57
DVDD4
58
TEST6
59
DVDDIO4
60
DVSS4
1u
6.3V
C506
1u
10V
C522
0.1u
C521
C512
0.1u
100k
R513
1u
6.3V
C503
0.1u
C519
RTQ035P02TR
Q502
1
3
4
2
5
6
6.3V
22u
C502
10uH
L503
0.1u
C525
1uH
L504
22u
6.3V
C504
C509
0.1u
0.1u
C524
0
R501
0.1u
C528
0.1u
C516
10V
22u
C530
1uH
L502
0.1u
C514
XC6219B302MR
IC503
1
2
3
45
6.3V
10u
C505
0.1u
C513
6.3V
47u
C531
0
R512
DTC144EMT2L
Q501
10V
22u
C501
1u
6.3V
C523
0.1u
C520
0.1u
C508
0.1u
C511
0.1u
C526
1u
6.3V
C529
1uH
L501
0.1u
C534
4700
R515
C535
0.1u
0.1u
C533
CL501
CL502
CL503
CL504
CL506
CL507
CL505
1K
R516
0
R517
0
R518
0
R519
470
R521
47k
R520
EMH10T2R
Q503
6
2
1
3
5
4
0.1u
C507
0.1u
C517
EMH10T2R
Q504
6
2
1
3
5
4
470
R505
47k
R504
6.3V
0.47u
C518
XC6219B10AMR
IC502
1
2
3
45
24P
CN501
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
22P
CN502
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
C527 0.1u
0
FB501
0
FB502
FB504
0
0
FB503
1
A
DRVOUT3
DRVOUT4
REFOUT3
DRVOUT1
REFOUT1
REFOUT4
REFOUT2
DRVOUT2
FD
HD
DRVOUT4
REFOUT3
REFOUT4
DRVOUT3
REFOUT2
REFOUT1
DRVOUT2
FD
DRVOUT1
HD
CKIN
CKIN
GND
REFOUT2
Vout
DRVOUT2(R)
GND
GND
-3.0V
GND
CE
REFOUT4
5.0V
Vout
CMOS_GP3_ON
SCK
SDI
VSUB_5V
CAM_4.7V1
GND
GND
REFOUT1
N.C
XCE
GND
GND
CE
REFOUT3
GND
DRVOUT3(Gb)
5.0V
HR
D_2.8V
CKIN
GND
VR
GND
GND
DRVOUT1(B)
Vin
CAM_2.8V
Vss
GND
GND
Vss
Vin
GND
N.C
DRVOUT4(Gr)
XCLR
GND
CAM_4.7V3
GND
GND
GND
CAM_2.8V
GND
IC501
CMOS IMAGER
IC503
3.0V REG
IC502
1.05V REG
SWITCH
SWITCH
B+ SWITCH
SWITCH
SY-132
CN102
(1/10)
of LEVEL3
CN101
PAGE 4-9
SY-132
(1/10)
D
F
B
E
5
3
H
C
6
12
2
9
11
7
G
4
10
05
8
CD-588 BOARD
CMOS IMAGER
IMG_TEMP (N.C.)
XX MARK:NO MOUNT
PAGE 4-9
of LEVEL3
(CD-591)
THROUGH THE
FLEXIBLE FLAT CABLE
(FP-313)
THROUGH THE
FLEXIBLE FLAT CABLE
6.3V
22u
C532
4-7
4-8
CD-558
DSC-R1_L2
Schematic diagrams of the SY-132 board are not shown.
Pages from 4-9 to 4-28 are not shown.
Pages from 4-9 to 4-28 are not shown.
DSC-R1_L2
4-29
4-30
LD-204, FP-309, AF-103
XX
R1036
R1030
XX
XX
D1003
3
2
1
XX
D1004
3
2
1
XX
D1002
3
2
1
XX
R1038
XX
R1037
XX
D1005
3
2
1
XX
R1041
XX
R1042
XX
R1043
XX
R1040
C1018 XX
ZOOM_POS
ZOOM_POS
LENS BLOCK is replaced as block,
so that there PRINTED WIRING BOARD
and SCHEMATIC DIAGRAM are omitted.
so that there PRINTED WIRING BOARD
and SCHEMATIC DIAGRAM are omitted.
R:REC MODE
P:PB MODE
P:PB MODE
NO MARK:REC/PB MODE
: Voltage measurement of the CSP ICs
and the Transistors with mark, are
not possible.
not possible.
Note: Parts other than connector and
LD-204 complete board are not supplied,
but they are included in lens assy repair (EK01A).
but they are included in lens assy repair (EK01A).
2.8
2.8
0.1
2.8
2.8
R0.2/P0
R0/P2.8
R0/P2.8
R0.1/P0
8.3
3.2
6
8.3
7.7
7.7
3.2
3.8
3.8
6
6
R1.1/P0.1
0
6
R0.3/P0.6
R0/P2.8
0
0
R1.1/P0.1
R1.1/P0.1
R1.1/P0.1
0
R0.3/P0.6
0
0
R0/P2.8
2.8
0
R0/P2.8
0
2.8
2.7
0
2.6
2.8
2.8
1.4
1.3
2.8
4.9
Note: D001 is not included in
AF-103 flexible board.
22u
6.3V
C1021
NJM2871BF28-TE2
IC1005
1
2
3
4
5
0.1u
C1017
0.001u
C1025
100k
R1033
0.0022u
C1003
47u
10V
10V
C1014
22u
6.3V
C1022
2700
±0.5%
R1017
39k
±0.5%
R1019
120k
R1034
0.1u
C1020
0.0022u
C1007
0.1u
C1004
0.1u
C1024
FB1001
10k
R1031
0.1u
C1026
0.1u
C1011
0.1u
C1010
±0.5%
33k
R1010
2700
±0.5%
R1011
±0.5%
33k
R1018
39k
±0.5%
R1012
BR9010RFVM-WTR
IC1003
1
CS
2
SCK
3
DI
4
DO
5
GND
6
RST
7
N.C
8
VCC
0.22u
C1023
82k
R1035
0.1u
C1019
10uH
L1001
±0.5%
1800
R1025
±0.5%
1800
R1024
1u
C1012
0.1u
C1006
2.2
R1015
1SS355TE-17
D1001
1500
R1008
0.01u
C1009
3900
R1007
0.1u
C1015
0.01u
C1008
2200
R1014
HN1C01FU-TE85R
Q1003
6
2
1
3
5
4
±0.5%
10k
R1022
±0.5%
3300
R1023
2.2
R1016
3300
R1009
MCH3306-TL-E
Q1004
1k
R1006
1200
R1013
LB1940U-TLM-E
IC1002
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
22u
10V
C1005
100
R1026
220
R1001
68k
R1004
68k
R1005
UP04116008S0
Q1001
6
2
1
3
5
4
UP04116008S0
Q1002
6
2
1
3
5
4
TC7S08FU(TE85R)
IC1004
123
4
5
1u
C1013
BU2343GLU-E2
IC1001
A1
C3
D3
B1
C2
E4
C1
D2
D1
E3
E2
E1
F3
F2
F1
F4
G4
G1
G2
G3
H1
H2
H3
J1
J2
K1
H4
K2
L1
J3
J4
L2
M1 K3 K4 M2 L3 J5 M3 L4 M4 K5 L5 M5 K6 L6 M6 J6 J7 M7 L7 K7 M8 L8 K8 M9 L9 M10 J8 L10 M11 K9 J9 L11
J10
L12
K11
H9
K12
J11
J12
H10
H11
H12
G10
G11
G12
G9
F9
F12
F11
F10
E12
E11
E10
D12
D11
C12
E9
C11
B12
D10
D9
B11
A12
C10
C9
A11
B10
D8
A10
B9
A9
C8
B8
A8
C7
B7
A7
D7
D6
A6
B6
C6
A5
B5
C5
A4
B4
A3
D5
B3
A2
C4
D4
B2
1M
R1027
5600
R1029
5600
R1020
1M
R1021
0
R1002
0
R1003
C1016
1u
±0.5%
820
R1028
22u
16V
C1002
22u
16V
C1001
CL1013
STATIC_GND
1SS355TE-17
D1006
CL1001
CL1002
CL1004
CL1006
CL1007
CL1009
CL1010
CL1012
CL1003
CL1008
CL1011
CL1005
6P
CN1003
1
2
3
4
5
6
51P
CN1002
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
39P
CN1001
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
LND019
LND023
LND021
LND022
LND018
OPY5252
D001
LND020
1
A
MSHUT_DIR
MSHUT_EN
XMF_SENS_LED
FC_RING_FGA
FC_RING_FGB
SYS_V
XIC_1001_RST
XIC_1001_CS
XLD_SCK
LD_SO
LD_SI
XLENS_EEP_CS
XLENS_EEP_WE
SPCK
HR_EN3
HR_DIR3B
HR_DIR3A
XFC_RST_SENS
XFC_RST_LED
XIRIS_RST_SENS
XIRIS_RST_LED
LENS_TEMP
FOCUS+
FOCUS-
IRIS_XA
IRIS_XB
IRIS_A
IRIS_B
IRIS_XA
IRIS_A
IRIS_XB
XFC_RST_SENS
FOCUS+
FOCUS-
IRIS_B
XMF_SENS_LED
XIRIS_RST_LED
XFC_RST_LED
XIRIS_RST_SENS
XFC_RST_SENS
LENS_TEMP
FC_RING_FGA
FC_RING_FGB
HR_DIR3A
HR_DIR3B
HR_EN3
MSHUT_EN
MSHUT_DIR
XLENS_EEP_WE
XLENS_EEP_CS
SYS_V
LD_SO
LD_SI
XIC_1001_CS
XIC_1001_RST
XLD_SCK
SPCK
OUT1
VDD
ENA1
RFG1
OUT3
ENA2
OUT2
IN1
VS2
IN2
VC1
OUT4
FC1
S_GND
VS1
FC2
VC2
RFG2
SVDD
VREF
IRIS_XB
IRIS_SENS_OUT
IRIS_CATHODE
SHUTTER+
THERM_OUT
FOCUS_SENS_GND
N.C.
N.C.
N.C.
MF_LED_ANODE
IRIS_A
ZOOM_POSI_OUT
MF_CATHODE
SHUTTER+
FOCUS_MR_GND
FOCUS_SENS_Vcc
MF_COLLECTOR
SHUTTER+
IRIS_SENS_Vcc
ZOOM_POSI_GND
FOCUS_SENS_OUT
MF_EMITTER2
FOCUS_MR_B
FOCUS-
SHUTTER-
SHUTTER-
ZOOM_POSI_Vcc
FOCUS_MR_A
SHUTTER-
N.C.
MF_EMITTER1
FOCUS+
SHUTTER-
SHUTTER+
N.C.
FOCUS_MR_Vcc
IRIS_EMITTER
IRIS_XA
IRIS_B
CLK
I_BIAS-
OUT1A
ZM_MR_B
EN4
RST_SENS1
PWM3
OUT3B
MGND3
ND_BIAS+
NC
TEST1
AD_FC_MR_A
OPOUT2
SI
EN0
NC
PWM2
FC_MR_A
CREFIN
DAC2OUT
NC
RST_SENS0
DAC3OUT
NC
XCLR
AD_IR
ND_HALL-
OPOUT3
DVSS
IR5
NC
AVDD
FC_MR_B
OPIN0N
OPIN3N
PWM4
I_HALL+
OUT4A
OPIN2N
I_HALL-
VD
REGOUT
OUT1B
CS
DAC0OUT
BR1
NC
AD_ND
ZM_MR_A
BR4
MGND5
OUT0A
NC
NC
AD_ZM_MR_B
OPIN1N
NC
IR7
TEST3(OPEN)
PWM1
TEST4(OPEN)
NC
EN2
NC
DAC6OUT
EN5
PWM5
OUT5A
NC
RVDD
OUT2B
NC
OPIN6N
NC
NC
AD_ZM_MR_A
AVSS
OUT2A
MVCC1
OPIN4N
AVSS
AD_FC_MR_B
DVDD
MVCC4
PWM0
NC
BR5
NC
EN3
VREF
SCK
NC
MGND1
TEST2
NC
OPOUT0
NC
DAC4OUT
NC
OPOUT4
MVCC3
MGND0
ND_BIAS-
MGND2
OPOUT1
MGND4
A
VSS
OPOUT6
SO
AV
D
D
MVCC2
OUT5B
ND_HALL+
EN1
OUT4B
OUT0B
MVCC0
A
VSS
MVCC5
NC
I_BIAS+
NC
VREG_PDWN
CLK_SEL
OUT3A
DAC1OUT
TEST0
XIC_1001_RST
ST_UNREG(SHUTTER)
HR_DIR3B
PGND
LD_SO
XIRIS_RST_SENS
XLENS_EEP_CS
SYS_V
ST_UNREG(SHUTTER)
LENS_TEMP
HR_EN3
XIC_1001_CS
REG_GND
XLD_SCK
D_2.8V
REG_GND
XIRIS_RST_LED
SPCK
D_2.8V
REG_GND
FC_RING_FGB
REG_GND
PRELAMP_CATHODE
CAM_P_5V
PGND
ST_UNREG(SHUTTER)
XFC_RST_SENS
HR_DIR3A
REG_GND
ZOOM_POS_OUT
PGND
PGND
XLENS_EEP_WE
REG_GND
FC_RING_FGA
XFC_RST_LED
REG_GND
REG_GND
REG_GND
MSHUT_DIR
CAM_P_5V
MSHUT_EN
PGND
LD_SI
REG_GND
REG_GND
XMF_SENS_LED
CAM_P_5V
REG_GND
CAM_P_5V
N.C.
N.C.
PRELAMP_ANODE
PRELAMP_ANODE
PRELAMP_CATHODE
PRELAMP_CATHODE
N.C.
IRIS DRIVE
FOCUS MOTOR DRIVE,
IC1001
EEPROM
IC1003
SHUTTER CONTROL
IC1004
SWITCH
SWITCH
SHUTTER MOTOR DRIVE
IC1002
6V REG
SWITCH
2.8V REG
IC1005
LD-204 BOARD
XX MARK:NO MOUNT
LENS DRIVE
28
XLENS_EEP_CS
PGND
MSHUT_DIR
5
17
HR_EN3
29
13
35
10
CAM_P_5V
3
REG_GND
D_2.8V
REG_GND
REG_GND
44
49
42
15
16
26
SY-LD
SPCK
48
XFC_RST_LED
32
37
XIC_1001_RST
LD_SI
SYS_V
21
REG_GND
36
LD_SO
XIRIS_RST_LED
23
REG_GND
7
LENS_TEMP
PGND
33
HR_DIR3A
31
REG_GND
BOARD
PGND
XIRIS_RST_SENS
PRELAMP_CATHODE
50
6
1
N.C.
27
REG_GND
HR_DIR3B
XIC_1001_CS
MSHUT_EN
ZOOM_POS_OUT
ST_UNREG(SHUTTER)
39
9
XLD_SCK
REG_GND
25
REG_GND
19
14
CAM_P_5V
45
REG_GND
ST_UNREG(SHUTTER)
XLENS_EEP_WE
47
34
24
CAM_P_5V
D_2.8V
8
51
38
11
18
43
ST_UNREG(SHUTTER)
41
CAM_P_5V
2
30
PGND
XFC_RST_SENS
40
PGND
REG_GND
REG_GND
12
XMF_SENS_LED
FC_RING_FGA
46
FC_RING_FGB
20
4
22
CONNECTION
BOARD
BOARD
FLEXIBLE
FP-309
HR_DIR3A
30
26
7
XLENS_EEP_WE
XIRIS_RST_LED
XLENS_EEP_CS
REG_GND
SYS_V
SY-132
27
PGND
11
43
CAM_P_5V
CAM_P_5V
35
ST_UNREG(SHUTTER)
PGND
3
14
38
CAM_P_5V
49
47
MSHUT_DIR
XFC_RST_LED
ST_UNREG(SHUTTER)
REG_GND
32
2
REG_GND
ZOOM_POS_OUT
4
31
XLD_SCK
28
20
1
21
REG_GND
46
REG_GND
HR_DIR3B
17
34
12
PRELAMP_CATHODE
41
9
MSHUT_EN
24
22
REG_GND
13
REG_GND
FC_RING_FGA
42
45
XFC_RST_SENS
SPCK
PGND
REG_GND
XIC_1001_CS
44
50
29
LD_SO
10
16
PAGE 4-27
XMF_SENS_LED
48
40
PGND
ST_UNREG(SHUTTER)
REG_GND
CAM_P_5V
HR_EN3
PGND
37
REG_GND
8
23
6
CN807
FC_RING_FGB
33
18
of LEVEL3
REG_GND
19
25
N.C.
D_2.8V
5
LD_SI
15
36
51
XIC_1001_RST
XIRIS_RST_SENS
(10/10)
D_2.8V
39
LENS_TEMP
REG_GND
2
6
AF ILLUMINATOR
SELF-TIMER/
5
N.C. 3
N.C.
1
PRELAMP_CATHODE
PRELAMP_ANODE
PRELAMP_ANODE
4
PRELAMP_CATHODE
AF-103
AF ILLUMINATOR
FLEXIBLE
BOARD
BOARD
24
19
D
F
17
B
13
21
23
E
16
5
J
3
20
N
H
C
6
12
2
18
M
9
14
11
7
G
4
L
22
10
I
15
05
K
8
K10
M12
LENS
BLOCK
Ver 1.1 2005.11
Click on the first or last page to see other DSC-R1 (serv.man2) service manuals if exist.