Sony DSC-TX66 (serv.man2) Service Manual ▷ View online
DSC-TX66_L2
2-3
2-1. EXPLODED VIEWS
2-1-1. FRONT SECTION
ns: not supplied
In this work, the preworked battery (insulated one) should be preliminarily inserted.
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1. Remove in numerical order (
1
to
7
) in the left figure.
2. The meaning of the symbol in left figure is as follows. Be careful when you remove it.
◇ -X
: Solder
DISASSEMBLY
1
#203/#249 X 6
: BT901 (LITHIUM RECHARGEABLE BATTERY)
Board on the mount position.
(See page 6-16 of Level 3)
Board on the mount position.
(See page 6-16 of Level 3)
5
(Claw)
7(Claw)
7(Claw)
1 (Claw)
3 (Claws)
3 (Claw)
Main Section
(See page 2-4)
SP901
BT901
5
14
15
16
18
20
19
5
4
2
4
8
(Note 2, 3, 4, 7)
3
7
5
6
7
3
(Note 5)
6
2
(Note 6)
1
1
#203
#249
(Note 1)
#249
(Note 1)
#203
#249
(Note 1)
#249
(Note 1)
#203
#249
(Note 1)
#249
(Note 1)
#203
#249
(Note 1)
#249
(Note 1)
11
9
10
(including CP1001
(CMOS imager))
(Note 2)
(CMOS imager))
(Note 2)
13
#30
12
17
(Note 4)
5 (Claws)
Bottom View
Left View
Right View
#203
#249
#249
#203
#249
#249
#203
#249
#249
Note
DISCHARGING OF THE CHARGING CAPACITOR
ストロボ用充電コンデンサの放電
2
CAUTION 1
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
注意 1
電池の交換は、正しく行わないと破裂する恐れがあります。電池を交
換する場合には必ず同じ型名の電池又は同等品と交換してください。
使用済み電池は、取扱指示に従って処分してください。
換する場合には必ず同じ型名の電池又は同等品と交換してください。
使用済み電池は、取扱指示に従って処分してください。
Note 4: Refer to “Assembly-3: Caution for Handling the Lens Device.”.
Note 4: “Assembly-3: Caution for Handling the Lens Device.” を参照
してください。
Note 5: Refer to “Assembly-1: The Method of attachment of RL-114
Flexible Board.”.
Note 5: “Assembly-1: The Method of attachment of RL-114 Flexible
Board.” を参照してください。
Note 7: G12 PROTECTION SHEET is supplied with the LSV-1501A
(SERVICE). This part is used to protect the LSV-1501A (SERVICE).
Remove this part when replacing the LSV-1501A (SERVICE).
Remove this part when replacing the LSV-1501A (SERVICE).
For the G12 PROTECTION SHEET, refer to “Assembly-3:
Caution for Handling the Lens Device.”
Caution for Handling the Lens Device.”
Note 7: LSV-1501A (SERVICE) にはG12 PROTECTION SHEETが付属さ
れています。これはLSV-1501A (SERVICE) を保護するためのシー
トです。LSV-1501A (SERVICE) 交換時は取り外して使ってくだ
さい。
トです。LSV-1501A (SERVICE) 交換時は取り外して使ってくだ
さい。
G12 PROTECTION SHEETについては Assembly-3: Caution for
Handling the Lens Device. を参照してください。
1
A-1869-632-A (FRONT (200)) S BLOCK ASSY (SILVER)
1
A-1869-633-A (FRONT (200)) N BLOCK ASSY (GOLD)
1
A-1869-634-A (FRONT (200)) P BLOCK ASSY (PINK)
1
A-1869-635-A (FRONT (200)) V BLOCK ASSY (VIOLET)
1
A-1869-636-A (FRONT (200)) W BLOCK ASSY (WHITE)
1
A-1869-637-A (FRONT (200)) R BLOCK ASSY (RED)
2
4-287-859-01
SHEET, FLEXIBLE RETAINER (Note 6)
3
A-1845-326-A RL-114 FLEXIBLE BOARD, COMPLETE (Note 5)
5
4-287-827-02 CUSHION,
MC
6
A-1863-910-A RL (200) S BLOCK ASSY (SILVER)
6
A-1863-911-A
RL (200) N BLOCK ASSY (GOLD)
6
A-1863-912-A RL (200) P BLOCK ASSY (PINK)
6
A-1863-913-A RL (200) V BLOCK ASSY (VIOLET)
6
A-1863-914-A RL (200) W BLOCK ASSY (WHITE)
6
A-1863-915-A RL (200) R BLOCK ASSY (RED)
7
4-417-442-01
CABINET (REAR (200)) (SILVER)
7
4-417-442-11
CABINET (REAR (200)) (GOLD)
7
4-417-442-21
CABINET (REAR (200)) (PINK)
7
4-417-442-31
CABINET (REAR (200)) (VIOLET)
7
4-417-442-41
CABINET (REAR (200)) (WHITE)
7
4-417-442-51
CABINET (REAR (200)) (RED)
8
A-1843-355-A LSV-1501A (SERVICE) (Note 2, 3, 4, 7)
9
4-274-499-01
PLATE, C LIGHT INTERCEPTION
10
1-856-268-21
OPTICALFILTER BLOCK (OFB-02-54)
11
4-274-511-01 RUBBER,
SEAL
12
4-287-817-01
CUSHION, CD FLEXIBLE
13
A-1860-141-A CD-829 FLEXIBLE BOARD, COMPLETE
(including CP1001(CMOS imager))(Note 2)
14
4-410-427-11 SHEET,
RL
ADHESIVE
15
4-411-464-01
INSULATING SHEET, RL
16
4-421-213-01
SHEET (200), SHUTTER (SW)
17
4-274-505-01
SEAL (1500), G10 (Note 4)
18
CAUTION 2
SHEET (2.5 X 13), ADHESIVE
19
4-423-096-01
SHEET (200), CABINET (REAR)
20
4-425-568-01
CUSHION (1.6 X 6.5)
BT901
1-853-130-11
LITHIUM BATTERY (SECONDARY)
SP901 1-858-302-31 LOUDSPEAKER
(0.8CM)
#30
3-086-156-11 SCREW
B1.2
#203
4-111-248-21
SCREW (M1.4), NEW, TRUSTAR (Note1)
#249
4-111-248-61
SCREW (M1.4), NEW, TRUSTAR (Note1)
Screw
#30: M1.2 X 3.5 (Tapping)
(White)
3-086-156-11
3-086-156-11
3.5
1.2
#203: M1.4X2.4
(Silver)
4-111-248-21
4-111-248-21
2.4
1.4
Screw's
Ref. No. (Parts Color.)
Ref. No. (Parts Color.)
Cabinet's Color
Table 2-1
Note 1:
#203 (Silver)
RED/SILVER/VIOLET
#249 (Black)
GOLD/PINK/WHITE
THE COMBINATION OF CABINET’S
COLOR AND SCREW
The screw pointed is different according
to the cabinet's color.
For the combination of cabinet's color and screw,
please refer to Table 2-1.
to the cabinet's color.
For the combination of cabinet's color and screw,
please refer to Table 2-1.
Note 2: Be sure to read “Precautions for Replacement of Imager” on
page 6-1 of Level3 when changing the imager.
Note 2: イメージャの交換時は Level3 の6-1ページ、“イメージャ交換時
の注意” を必ずお読みください。
Note 3: Refer to “Assembly-2: Precaution During of Lens Flexible Board
Removing.”.
Note 3: “Assembly-2: Precaution During of Lens Flexible Board
Removing.” を参照してください。
Note 6: Refer to “Assembly-4: Precaution During of Flexible Retainer
Sheet.”.
Note 6: “Assembly-4: Precaution During of Flexible Retainer Sheet.”
を参照してください。
Note on assembling (About the work to the battery)
組立て時の注意（ バッテリーの加工方法について）
#249:
M1.5 X 2.4
(Black)
4-111-248-61
(Black)
4-111-248-61
2.4
1.5
CAUTION 2
For the part of 18 : SHEET (2.5 X 13), ADHESIVE, cut
SHEET, ADHESIVE (2-649-300-01) into the desired
length and use it.
SHEET, ADHESIVE (2-649-300-01) into the desired
length and use it.
注意 2
18 : SHEET (2.5 X 13), ADHESIVEは、SHEET, AD-
HESIVE (2-649-300-01) を切って使用すること。
The changed portions from
Ver. 1.5 are shown in blue.
Ver. 1.5 are shown in blue.
Ver. 1.6 2013.08
DSC-TX66_L2
2-4
2-1-2. MAIN SECTION
ns: not supplied
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
DISASSEMBLY
Note
1. Remove in numerical order (
1
to
4
) in the left figure.
3
#203 X 2
Front View
#203
Screw
#203: M1.4X2.4
(Silver)
4-111-248-21
4-111-248-21
2.4
1.4
Battery Holder Section
(See page 2-5)
1
59
3
51
4
55
(Note 2)
2
EL901
(Note 1
, 3
)
58
ns
#203
52
54
53
57
56
(Claw)
2 (Claw)
(Claw)
60
2 (Claws)
1 (Claws)
SY
-332
61
(Claws)
Hold the EL Unit at the four corners.
Claw
Claw
Corner of
the OLED
the OLED
Center
Center
Corner of
the OLED
the OLED
Flexible Board
EL Unit
Claw
Do not hold the following part.
Note 1:
CAUTION FOR HANDLING THE EL UNIT
51
4-287-853-01
SHEET METAL, CN RETAINER
52
A-1845-325-A HD-044 FLEXIBLE BOARD, COMPLETE
53
4-287-857-01
INSULATING SHEET (A), SY
54
4-292-298-01
INSULATING SHEET (A-R), SY
55
A-1863-632-A SY-332 BOARD, COMPLETE (SERVICE) (Note 2)
56
4-294-395-01 SHEET,
TERMINAL
MOLD
ADHESIVE
57
4-290-431-01 MOLD,
TERMINAL
58
4-290-432-01
SHEET METAL, STRAP BASE
59
4-287-850-11 BASE,
STRAP
60
4-287-861-01 SHEET,
TPFPC
61
4-400-504-01 CUSHION,
ASM
EL901
A-1872-477-A DISPLAY MODULE (MD11E-WCSUS) (Note 1
, 3
)
#203
4-111-248-21
SCREW (M1.4), NEW, TRUSTAR
Note 2: TERMINAL MOLD and TERMINAL MOLD ADHESIVE SHEET
are supplied with the SY-332 COMPLETE BOARD (SER-
VICE).
VICE).
These two parts are used to protect the battery terminals on
the SY-332 COMPLETE BOARD (SERVICE) .
the SY-332 COMPLETE BOARD (SERVICE) .
Remove these two parts when replacing the SY-332 COM-
PLETE BOARD (SERVICE) .
PLETE BOARD (SERVICE) .
Do not bend battery terminals.
Note 2: SY-332 COMPLETE BOARD (SERVICE) には TERMINAL
MOLD と TERMINAL MOLD ADHESIVE SHEET が付属され
ています。
ています。
これらは SY-332 COMPLETE BOARD (SERVICE) のバッテ
リー端子を保護するための梱包材です。
SY-332 COMPLETE BOARD (SERVICE) 交換時は、この２
つを取り外して使ってください。
つを取り外して使ってください。
また、バッテリー端子を曲げないように注意してください。
The changed portions from
Ver. 1.3 are shown in blue.
Ver. 1.3 are shown in blue.
Ver. 1.4 2012.09
Note 3: Refer to “1-9. PRECAUTION ON REPLACING THE DISPLAY
MODULE” on page 1-4 when replacing the EL901.
Note 3: EL901 の交換を行う場合，1-7ページの 1-9. ディスプレイモ
ジュール交換時の注意 を参照してください。
DSC-TX66_L2
2-5
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
Note
111
110
109
112
113
107
#82
104
103
(Note)
108
106
114
114
101
102
C901
#82
105
ns
ns
ns
ns
Screw
#82: M1.4 X 1.4
(Silver)
3-272-251-01
3-272-251-01
1.4
1.4
Note : Refer to “Assembly-5: The Method of folding of the
Flash Unit Flexible Board.”.
Note : “Assembly-5: The Method of folding of the Flash Unit
Flexible Board.” を参照してください。
101
4-400-321-01 CUSHION,
ST
102
4-287-860-01 SHEET,
MAINCON.
103
1-489-927-11
FLASH UNIT (Note)
104
4-294-023-01
SHEET (SM), RADIATION
105
4-292-297-01
SHEET METAL, RADIATION
106
A-1863-923-A BTH (200) S BLOCK ASSY (SILVER)
106
A-1863-924-A BTH (200) N BLOCK ASSY (GOLD)
106
A-1863-925-A BTH (200) P BLOCK ASSY (PINK)
106
A-1863-926-A BTH (200) V BLOCK ASSY (VIOLET)
106
A-1863-927-A BTH (200) W BLOCK ASSY (WHITE)
106
A-1863-928-A BTH (200) R BLOCK ASSY (RED)
107
4-287-834-01
SHAFT, BT LOCK
108
4-287-856-01 NUT,
M3
109
4-287-831-01
PLATE, BT LID HINGE
110
4-287-848-01
CLAW, BT LID LOCK (WHITE)
110
4-287-848-11
CLAW, BT LID LOCK (EXCEPT WHITE)
111
4-287-846-01
LID, BT (WHITE)
111
4-417-440-01
LID (200), BT (SILVER)
111
4-417-440-11
LID (200), BT (GOLD)
111
4-417-440-21
LID (200), BT (PINK)
111
4-417-440-31
LID (200), BT (VIOLET)
111
4-417-440-41
LID (200), BT (RED)
112
4-287-836-01
SPRING, BT LID
113
4-287-832-01
SHAFT, BT HINGE
114
4-294-660-01
CUSHION (2), MC
C901
1-116-458-21
ELECT 37uF 315V
#82
3-272-251-01
SCREW (M1.4), HEAD PRECISION
2-1-3. BATTERY HOLDER SECTION
ns: not supplied
DSC-TX66_L2
2-6E
ACCESSORIES
901
902
903
904
905
906
907
908
909
This item is supplied with the unit as an accessory, but is not prepared as a service part.
951
Ref. No. Part No.
Description
951
(Not supplied) Rechargeable battery pack (NP-BN)
Note: This unit has no bundled CD-ROM.
Contents included in the CD-ROM will be supplied to customers as
follows.
Contents included in the CD-ROM will be supplied to customers as
follows.
・ User Guide (HTML)
- You can access the URL of the support site described in the
Instruction Manual.
- All of the contents in the User Guide are included in the Instruction
Manual or built-in guide.
・ Application Software
- By connecting this unit and Windows PC with the USB cable, the
application software [PlayMemories Home Lite version] can be
installed on the PC from the unit.
installed on the PC from the unit.
- In case of using the extended version, install “Expanded Feature”
via Internet.
Ref. No. Part No.
Description
901
1-489-282-11
AC Adaptor AC-UB10/UB10B (J)
901
1-489-282-21
AC Adaptor AC-UB10/UB10B (US, CND)
901
1-489-282-31
AC Adaptor AC-UB10/UB10B (CH)
901
1-489-282-61
AC Adaptor AC-UB10/UB10B (EXCEPT US, CND, CH, J)
902
1-837-421-11
Power cord (mains lead) (UK, E (Saudi), HK)
902
1-837-422-11
Power cord (mains lead) (JE)
902
1-837-424-11
Power cord (mains lead) (TW)
902
1-837-427-11
Power cord (mains lead) (AEP, E (EXCEPT Saudi))
902
1-837-428-11
Power cord (mains lead) (KR)
903
1-569-007-12
Conversion (2P) Adaptor (JE)
904
1-569-008-33
Conversion (2P) Adaptor (E: NTSC)
905
1-838-826-11
Multi-use terminal USB cable
906
4-279-876-01 Paint
pen
907
2-050-981-11 Wrist
strap
908
X-2583-744-1 Tripod
adaptor
909
4-417-595-01
Instruction Manual (JAPANESE)
909
4-417-595-11
Instruction Manual (SIMPLIFIED CHINESE)
909
4-417-596-11
Instruction Manual (ENGLISH)
* 909
4-417-596-21
Instruction Manual (ENGLISH, SPANISH)
* 909
4-417-596-31
Instruction Manual (ENGLISH, FRENCH)
* 909
4-417-596-41
Instruction Manual (ENGLISH, RUSSIAN, UKRAINIAN)
* 909
4-417-596-51
Instruction Manual (ENGLISH, FRENCH, ITALIAN,
SPANISH, PORTUGUESE, GERMAN, DUTCH,
TURKISH, GREEK, POLISH, CZECH, HUNGARIAN,
SLOVAK, SWEDISH, FINNISH, NORWEGIAN,
DANISH, CROATIAN, ROMANIAN)
* 909
4-417-596-61
Instruction Manual (ENGLISH, TRADITIONAL
CHINESE, SIMPLIFIED CHINESE, MALAY,
INDONESIAN,
THAI,
ARABIC,
PERSIAN)
Ref. No. Part No.
Description
* 909
4-417-596-71 Instruction Manual
(ENGLISH, SPANISH, PORTUGUESE)
* 909
4-417-596-81
Instruction Manual (ENGLISH, TRADITIONAL
CHINESE, SIMPLIFIED CHINESE, INDONESIAN,
ARABIC,
PERSIAN)
* 909
4-417-596-91
Instruction Manual (ENGLISH, SPANISH,
PORTUGUESE, TRADITIONAL CHINESE, SIMPLIFIED
CHINESE,
KOREAN)
* 909
4-417-597-11
Instruction Manual (ENGLISH, TRADITIONAL
CHINESE, SIMPLIFIED CHINESE)
909
4-417-597-21
Instruction Manual (KOREAN)
* 909
4-417-597-41 Instruction Manual
(ENGLISH,
TRADITIONAL
CHINESE)
* 909
4-417-597-51
Instruction Manual (ENGLISH, ARABIC, PERSIAN)
Ver. 1.2 2012.05
Click on the first or last page to see other DSC-TX66 (serv.man2) service manuals if exist.