Sony NW-A3000 Service Manual ▷ View online
49
NW-A3000
Pin No.
Pin Name
I/O
Description
52
CRST1
O
External capacitor connection terminal for reset delay (for XRST1)
53
CRST2
O
External capacitor connection terminal for reset delay (for XRST2)
54
CRST3
O
External capacitor connection terminal for reset delay (for XRST3)
55
SEQSEL
I
LDO output trigger selection signal input terminal "L": VO interlock, "H": XRST interlock
Fixed at "L" in this set
Fixed at "L" in this set
56
SEL1
I
LDO1 and LDO3 power output control selection signal input terminal
"L": When VBUS is detected, power is output, "H": power is always output
Fixed at "H" in this set
"L": When VBUS is detected, power is output, "H": power is always output
Fixed at "H" in this set
57
SEL2
I
LDO1 and LDO3 power output control selection signal input terminal
"L": according to the setting of SEL1, "H": power is output at a normal sequence
Fixed at "H" in this set
"L": according to the setting of SEL1, "H": power is output at a normal sequence
Fixed at "H" in this set
58
DCIN_MON
I
DC power input monitor input terminal
59
VBUSIN
I
VBUS power supply input terminal (+5V)
60
VBUS_LIM
I
USB current limit control signal input from the PLD "L": 100 mA, "H": 500 mA
61
VBATT
I
Battery power supply input terminal (+3.7V)
62
BATTMON
O
Battery voltage monitor output to the main system controller
63
BATTMON_CTL
I
Battery voltage monitor on/off control signal input from the PLD
"H": battery voltage monitor on
"H": battery voltage monitor on
64
XDCIN_DET
O
DC power detection signal output terminal
65
XVBUS_DET
O
VBUS power detection signal output terminal
66
VBUSSUSPEND
I
Setting terminal for the USB suspend mode "H": USB suspend mode
67
XCHG_STAT1
O
Charging flag output terminal "L" active
68
XCHG_STAT2
O
Charge completion flag output terminal "L" active
69
TS
I
Temperature sensor input terminal
70
LOGIC_H
I
Power supply input terminal (+3V) (for logic "H")
71
CS
I
Chip select signal input from the PLD "H" active
72
SCK
I
Serial data transfer clock signal input from the PLD
73
SI
I
Serial data input from the PLD
74
SO
O
Serial data output to the main system controller
75
XGND_SW
O
Ground switch terminal for the remote commander
76
GPIO0
O
DC power on/off control signal output terminal "H": power on
77
GPIO1
O
Charge on/off control signal output terminal "L": charge on
78
RST
O
System reset signal input from the reset switch "L": reset
For several hundreds msec. after the power supply rises, "L" is input, then it change to "H"
For several hundreds msec. after the power supply rises, "L" is input, then it change to "H"
79
RMON11
I
External resistor return terminal
80
RMON12
I
External resistor return terminal
81
RMON21
I
External resistor return terminal
82
RMON22
I
External resistor return terminal
83
GATE1
O
VBUS or DC/battery power selection signal output terminal
"L": battery power, "H": VBUS or DC power
"L": battery power, "H": VBUS or DC power
84, 85
GATE2, GATE3
O
Battery power on/off control signal output terminal "H": power on
86
CHGREG
O
Reference voltage (+2.4V) output terminal for charge circuit
87, 88
VCC
-
Power supply terminal (+3.7V)
89 to 91
GND
-
Ground terminal
92
BGGND
-
Ground terminal (for BG)
93
DISGND
-
Ground terminal (for discharge)
94 to 96
TEST1 to TEST3
I
Input terminal for the test mode setting
97
TEST4
O
Output terminal for the test mode setting
98 to 100
NC
-
Not used
50
NW-A3000
SECTION 6
EXPLODED VIEWS
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
1
X-2103-485-1 BUTTON S SUB ASSY (SILVER)
1
X-2103-486-1 BUTTON V SUB ASSY (VIOLET)
1
X-2108-230-1 BUTTON B SUB ASSY (BLACK)
2
2-652-185-01 ORNAMENT (BUTTON)
3
2-651-509-02 CABINET (INNER) (SILVER)
3
2-651-509-12 CABINET (INNER) (VIOLET)
3
2-651-509-22 CABINET (INNER) (BLACK)
4
2-662-683-03 SHIELD (CABINET)
5
2-651-508-02 CABINET (UPPER) (VIOLET)
5
2-651-508-12 CABINET (UPPER) (SILVER)
5
2-651-508-22 CABINET (UPPER) (BLACK)
6
2-651-511-01 BUTTON (RESET)
7
X-2109-031-1 CABI (REAR) ASSY (V) (VIOLET)
7
X-2109-032-1 CABI (REAR) ASSY (S) (SILVER)
7
X-2109-033-1 CABI (REAR) ASSY (B) (BLACK)
8
3-225-873-09 SCREW (M1.4)
9
2-651-520-01 EMBLEM (W DOT)
10
X-2103-482-1 BATTERY SUB ASSY (CND)
10
X-2108-661-1 BATTERY SUB ASSY
(AEP, UK, SP, KR, AUS, CH, JE)
11
3-318-201-01 SCREW (B) (1.4X3), TAPPING
12
2-651-521-01 SHEET (EMBLEM), ADHESIVE
13
2-665-631-01 SHEET (ELECTROSTATIC G)
14
2-634-752-11 CUSHION, HDD1.5 B
15
2-665-586-01 SHEET (ELECTROSTATIC D)
16
2-587-084-01 SHEET (A), ELECTROSTATIC
17
2-667-644-01 SHEET (INSULATING CL) (AEP, UK, SP, KR, JE)
18
2-662-874-01 SHEET (CAB UPPER)
19
2-665-584-01 SHEET (ELECTROSTATIC B)
20
2-667-021-11 SHEET (ELECTROSTATIC K)
(AEP, UK, SP, KR, JE)
6-1.
CABINET SECTION
•
Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
•
The mechanical parts with no reference
number in the exploded views are not supplied.
number in the exploded views are not supplied.
•
Accessories are given in the last of the
electrical parts list.
electrical parts list.
NOTE:
•
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
may have some difference from the original
one.
•
Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color
Cabinet's Color
1
2
3
4
6
10
8
16
14
9
12
11
7
main section
(AEP, UK, SP, KR, JE)
15
19
13
14
20
17
20
20
Note: Execute the confirmation and the inspection of the correct repair of all parts
after it repairs. And, install emblem (W dot) (Ref.No. 9) and
adhesive sheet (emblem) (Ref.No. 9) after confirming the repair ended completely.
adhesive sheet (emblem) (Ref.No. 9) after confirming the repair ended completely.
18
18
5
•
Refer to Servicing Notes “color variation”
(page 3) about color variation.
(page 3) about color variation.
•
Abbreviation
AUS : Australian model
CH : Chinese model
CND: Canadian model
AUS : Australian model
CH : Chinese model
CND: Canadian model
Ver. 1.5
JE
: Tourist model
KR : Korean model
SP : Singapore model
SP : Singapore model
51
NW-A3000
62
61
79
84
76
60
85
59
58
57
73
63
68
69
70
71
74
55
56
54
53
52
95
75
85
51
56
88
88
88
56
56
65
83
82 78
(AEP, UK, SP, KR, JE)
(CND, AUS)
(AEP, UK, SP, KR, JE)
(AEP, UK,
SP, KR, JE)
SP, KR, JE)
81
81
80
97
98
98
51
87
85
85
85
90
Note: Refer to Servicing Notes “description of HDD unit section and notes on replacement
of HDD unit section” (page 3) when you exchange HDD unit section (Ref.No.57, 58, 73, 74, 77).
97
66
86
64
54
51
67
96
85
92
93
(SILVER only)
91
99
77
(for TOSHIBA
HDD UNIT)
HDD UNIT)
6-2.
MAIN SECTION
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
51
3-254-135-01 SCREW (B1.4)
52
X-2103-467-1 MAIN BOARD, COMPLETE (for SERVICE)
53
2-661-273-01 SHEET (MAIN PWB)
54
3-252-823-01 SCREW (B1.4)
55
2-651-517-01 BRACKET (HDD)
56
2-661-274-01 SHEET (BRACKET)
57
1-868-525-11 FLEXIBLE BOARD (for TOSHIBA HDD UNIT)
57
1-868-526-11 FLEXIBLE BOARD (for HITACHI HDD UNIT)
58
2-653-380-01 INSULATOR (T1.8) (for TOSHIBA HDD UNIT)
58
2-653-382-01 INSULATOR (HL1.8) (for HITACHI HDD UNIT)
59
2-655-208-01 REINFORCEMENT (CONNECTOR)
60
X-2149-450-1 CONNECTOR BOARD, COMPLETE
(for SERVICE)
61
1-868-523-11 FLEXIBLE BOARD
62
2-651-516-01 CABINET (MIDDLE)
63
1-479-535-11 SWITCH UNIT
64
X-2103-476-1 EL SUB ASSY
65
2-651-513-01 BUTTON (LINK) (VIOLET)
65
2-651-513-11 BUTTON (LINK) (SILVER)
65
2-651-513-21 BUTTON (LINK) (BLACK)
66
1-868-524-11 FLEXIBLE BOARD
67
X-2149-449-1 HP BOARD, COMPLETE (for SERVICE)
68
2-651-512-01 BUTTON (HOLD)
69
2-654-434-01 KNOB (VOL)
70
2-654-435-01 LEVER (VOL)
71
3-631-895-01 SCREW, STEP
73
1-479-527-11 HDD UNIT (20GB) (HITACHI HDD UNIT)
73
1-479-528-11 HDD UNIT (20GB) (TOSHIBA HDD UNIT)
74
2-653-380-01 INSULATOR (T1.8) (for TOSHIBA HDD UNIT)
74
2-653-383-01 INSULATOR (HR1.8) (for HITACHI HDD UNIT)
75
2-664-878-01 SHEET (HOLDSW)
76
1-780-334-11 TERMINAL BOARD
77
2-629-604-61 CUSHION (HDD1.5) (for TOSHIBA HDD UNIT)
78
2-664-877-01 SHEET (CABINET MIDDLE)
79
2-667-275-01 CUSHION (FPC)
80
2-665-690-01 SHEET (MIRROR)_MC
81
2-665-692-01 SHEET (MIRROR)_CO
82
2-663-025-01 SHEET (LINK)
83
2-666-408-01 SHEET (STOPPER LINK)
84
2-663-331-01 SCREW (B1.4X3)
85
2-587-084-01 SHEET (A), ELECTROSTATIC
86
2-666-407-01 SHEET (HP PWB)
87
2-667-274-01 CUSHION (BRACKET-FPC)
88
2-667-021-01 SHEET (ELECTROSTATIC K)
(AEP, UK, SP, KR, JE)
90
2-664-878-11 SHEET (HOLD SW)
91
2-666-409-02 SHEET (ELECTROSTATIC H) (CND, AUS)
92
2-666-952-01 SHEET (ELECTROSTATIC I)
(AEP, UK, SP, KR, JE)
93
2-664-770-01 SHEET (OEL) (SILVER only)
95
2-666-313-01 SHEET (LEAKAGE)
96
2-667-632-01 SHEET (HP PWB B) (AEP, UK, SP, KR, JE)
97
2-670-100-02 SHEET (SIDE)
98
2-672-298-01 SHEET, SUPPORT
99
2-629-604-71 CUSHION (HDD1.5)
Ver. 1.4
52
NW-A3000
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
SECTION 7
ELECTRICAL PARTS LIST
NOTE:
•
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
•
-XX and -X mean standardized parts, so they
may have some difference from the original
one.
may have some difference from the original
one.
•
RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
•
Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
•
SEMICONDUCTORS
In each case, u:
In each case, u:
µ
, for example:
uA... :
µ
A...
uPA... :
µ
PA...
uPB... :
µ
PB...
uPC... :
µ
PC...
uPD... :
µ
PD...
•
CAPACITORS
uF:
uF:
µ
F
•
COILS
uH:
uH:
µ
H
HP
CONNECTOR
X-2149-450-1 CONNECTOR BOARD, COMPLETE
(for SERVICE)
***************************
< CAPACITOR >
C901
1-100-504-11 CERAMIC CHIP
0.1uF
20%
6.3V
C902
1-164-943-11 CERAMIC CHIP
0.01uF
10%
16V
< CONNECTOR >
CN901
(Not supplied) CONNECTOR, MULTIPLE (SOCKET)
CN902
1-818-537-21 CONNECTOR, FPC (ZIF) 11P
CN903
1-819-823-11 CONNECTOR, FPC (ZIF) 35P
< RESISTOR/FERRITE BEAD >
R5057
1-218-990-11 SHORT CHIP
0
R5063
1-400-693-21 INDUCTOR, FERRITE BEAD (1005)
R5064
1-218-990-11 SHORT CHIP
0
R5065
1-218-990-11 SHORT CHIP
0
R5066
1-218-990-11 SHORT CHIP
0
R5067
1-218-990-11 SHORT CHIP
0
R5068
1-218-990-11 SHORT CHIP
0
R5069
1-218-990-11 SHORT CHIP
0
R5070
1-218-990-11 SHORT CHIP
0
R5071
1-218-990-11 SHORT CHIP
0
R5072
1-208-683-11 METAL CHIP
1K
0.5%
1/16W
R5077
1-218-990-11 SHORT CHIP
0
< SWITCH >
S901
1-786-845-11 SWITCH, TACTILE (RESET)
************************************************************
X-2149-449-1 HP BOARD, COMPLETE (for SERVICE)
*******************
< CAPACITOR >
C104
1-137-987-11 CERAMIC CHIP
0.068uF
10%
10V
C204
1-137-987-11 CERAMIC CHIP
0.068uF
10%
10V
C301
1-107-726-91 CERAMIC CHIP
0.01uF
10%
16V
C303
1-107-726-91 CERAMIC CHIP
0.01uF
10%
16V
C304
1-125-891-11 CERAMIC CHIP
0.47uF
10%
10V
C307
1-164-943-11 CERAMIC CHIP
0.01uF
10%
16V
< CONNECTOR >
CN301
1-818-537-21 CONNECTOR, FPC (ZIF) 11P
< DIODE >
D302
6-500-776-01 DIODE MAZW068H0LS0
D304
6-500-776-01 DIODE MAZW068H0LS0
D305
6-500-776-01 DIODE MAZW068H0LS0
D306
8-719-421-69 DIODE MA133
D307
8-719-083-91 DIODE EDZ TE61 6.8B
D308
8-719-083-91 DIODE EDZ TE61 6.8B
< FERRITE BEAD/RESISTOR >
FB101
1-400-808-21 INDUCTOR (EMI FERRITE) (1608)
FB202
1-400-808-21 INDUCTOR (EMI FERRITE) (1608)
FB301
1-400-693-21 INDUCTOR, FERRITE BEAD (1005)
FB302
1-218-941-11 RES-CHIP
100
5%
1/16W
FB303
1-400-198-21 INDUCTOR, FERRITE BEAD (1005)
FB304
1-400-461-21 FERRITE, EMI (SMD) (1005)
FB305
1-400-808-21 INDUCTOR (EMI FERRITE) (1608)
< JACK >
J301
1-817-933-21 JACK (i)
< TRANSISTOR >
Q101
8-729-050-32 TRANSISTOR
2SC5585TL
Q201
8-729-050-32 TRANSISTOR
2SC5585TL
< RESISTOR >
R102
1-244-161-11 RES-CHIP
2.2
5%
1/16W
R103
1-218-957-11 RES-CHIP
2.2K
5%
1/16W
R202
1-244-161-11 RES-CHIP
2.2
5%
1/16W
R203
1-218-957-11 RES-CHIP
2.2K
5%
1/16W
< SWITCH >
S8301
1-786-910-11 SWITCH, SLIDE (VOL +/–)
************************************************************
X-2103-467-1 MAIN BOARD, COMPLETE (for SERVICE)
*********************
< CAPACITOR/RESISTOR >
C305
1-164-943-11 CERAMIC CHIP
0.01uF
10%
16V
MAIN
•
Abbreviation
AUS : Australian model
CH
AUS : Australian model
CH
: Chinese model
CND : Canadian model
Note: CN901 on the CONNECTOR board cannot exchange with single.
When CN901 is damaged, exchange the entire mounted board.
Ver. 1.5
JE
: Tourist model
KR
: Korean model
SP
: Singapore model
When indicating parts by reference
number, please include the board.
number, please include the board.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Click on the first or last page to see other NW-A3000 service manuals if exist.