Sony HDR-CX570E / HDR-CX580E / HDR-CX580V / HDR-CX580VE / HDR-CX590V / HDR-PJ580 / HDR-PJ580E / HDR-PJ580V / HDR-PJ580VE / HDR-PJ590V / HDR-PJ600 / HDR-PJ600E / HDR-PJ600V / HDR-PJ600VE (serv.man2) Service Manual ▷ View online
2-7
HDR-CX570E/CX580E/CX580V/CX580VE/CX590V/PJ580/PJ580E/PJ580V/PJ580VE/PJ590V/PJ600E/PJ600V/PJ600VE_L2
2-1-5. OVERALL SECTION -2
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
201
4-274-987-01
TAPE (AS 1/2) (C)
#2
2-635-562-31 SCREW
(M1.7)
#3
2-660-401-01
SCREW (M1.7), NEW TRU-STAR, P2
1. Remove to numerical order (
1
to
3
) in the left figure.
DISASSEMBLY
Right View
Top View
#2
#3
1
#3 X 3 → #2 X 2
Top View
Right View
#3
#2
2
#2 X 1 → #3 X 2
Screw
#2: M1.7 X 4.0
(Black)
2-635-562-31
2-635-562-31
4.0
1.7
#3: M1.7 X 2.5
(Red)
2-660-401-01
2-660-401-01
2.5
1.7
Note
Note:
Refer to "Assembly-3: Installation Cautions of the Front
Panel Section.".
Panel Section.".
Note:
Assembly-3: Installation Cautions of the Front Panel
Section.. を参照してください。
Projector Model
HDD Model
Non HDD Model
Non Projector Model
#2
#2
#2
#3
#3
1
Battery Panel Section
(See page 2-10)
3
Cabinet (R) Section
(See page 2-11)
2
Front Panel Section
(See page 2-9)
(Note)
#3
#3
#3
201
#3
Lens Section
(See page 2-8)
Right View
Right View
Front View
Bottom View
#3
#3
#3
#2
3
#3 X 3 → #2 X 1
2-8
HDR-CX570E/CX580E/CX580V/CX580VE/CX590V/PJ580/PJ580E/PJ580V/PJ580VE/PJ590V/PJ600E/PJ600V/PJ600VE_L2
251
A-1856-574-A LED BLOCK ASSY (386B), ST
252
A-1853-602-A ST-248 BOARD, COMPLETE
253
1-882-882-11
FP-1327 FLEXIBLE BOARD
254
1-882-883-11
FP-1328 FLEXIBLE BOARD
255
1-818-890-11
CONNECTOR, EXTERNAL (HOT SHOE)
256
4-271-966-01 FRAME,
SHOE
257
4-279-796-01 GASKET
(TOP)
258
4-271-724-01
HEAT SINK (L) (381) (Non HDD Model)
258
4-271-724-11
HEAT SINK (L) (381) (HDD Model)
259
4-271-723-01
FRAME (L) (381), LENS
260
A-1851-196-A CM-123 BOARD, COMPLETE
(including CP001 (CMOS Imager)) (Note 1)
261
3-216-044-01
RUBBER (1270), SEAL
262
1-856-172-21
FILTER BLOCK, OPTICAL (Note 2, 3)
263
1-856-171-21
FILTER BLOCK, OPTICAL (Note 2, 3)
264
1-884-929-21
FP-1488 FLEXIBLE BOARD
265
4-408-191-01
SHEET (CM (385)), SHIELD
266
A-1733-588-A DEVICE, LENS LSV-1400A (SERVICE)
267
4-276-408-01
SHEET (FPC (LENS))
268
A-1861-126-A VC-653 BOARD, COMPLETE (SERVICE)
(CX570E/CX580E/CX580V/CX580VE/CX590V)
268
A-1861-127-A VC-653 BOARD, COMPLETE (SERVICE)
(PJ580/PJ580E/PJ580V/PJ580VE/PJ590V)
268
A-1861-128-A VC-653 BOARD, COMPLETE (SERVICE)
(PJ600E/PJ600V/PJ600VE)
269
4-282-564-01 SHEET
(KZ)
270
A-1851-197-A LD-279 BOARD, COMPLETE (PJ580/PJ580E)
270
A-1851-199-A LD-279 BOARD, COMPLETE (CX580E)
270
A-1857-361-A LD-279 BOARD, COMPLETE (CX570E)
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
270
A-1860-725-A LD-279 BOARD, COMPLETE (PJ600E/PJ600V/PJ600VE)
270
A-1861-129-A LD-279 BOARD, COMPLETE (SERVICE) (CX590V)
270
A-1861-130-A LD-279 BOARD, COMPLETE (SERVICE)
(PJ580V/PJ580VE)
270
A-1861-131-A LD-279 BOARD, COMPLETE (SERVICE) (PJ590V)
270
A-1862-435-A LD-279 BOARD, COMPLETE (SERVICE)
(CX580V/CX580VE)
271
4-286-711-01
SHEET (AV), RADIATION (HDD Model) (Note 5)
272
1-882-736-21
FP-1313 FLEXIBLE BOARD
273
4-272-050-01
SHEET (MM), SHIELD
274
4-271-964-01
FRAME (R), LENS
275
4-279-575-01
PLATE (FRAME R), GROUND
276
4-271-965-01
HEAT SINK (R)
277
4-271-967-01
SHEET, CM RADIATION (HDD Model) (Note 5)
278
4-271-968-01
SHEET (HEAT SINK R)
279
4-271-969-01
SHEET (FRAME R)
280
4-286-712-01
SHEET (CO), RADIATION (HDD Model) (Note 5)
281
4-282-293-01
SHEET (ST (381)), SHIELD
C7210
1-116-781-11
DOUBLE LAYERS 0.35F 20% 5.5V (Note 4)
#1
2-635-562-11 SCREW
(M1.7)
#2
2-635-562-31 SCREW
(M1.7)
#3
2-660-401-01
SCREW (M1.7), NEW TRU-STAR, P2
#12
3-080-204-21 SCREW,
TAPPING,
P2
#172
2-178-410-01
TITE (UB TITE) 1.4
2-1-6. LENS SECTION
ST
-248
LD-279
VC-653
HDD Model
#2
251
281
#3
#3
#3
C7210
(Note 4)
(Note 4)
#12
#12
#3
#172
#3
#1
#3
#1
#3
#3
260
(including CP001 (CMOS imager))
(Note 1)
(Note 1)
2
270
3
268
5
266
267
265
269
263
(Note 2, 3)
262
(Note 2, 3)
261
264
272
1
252
254
256
253
4
255
276
5
-2
274
5
-2
259
5
-3
258
5
-3
279
280
(Note 5)
278
271
(Note 5)
277
(Note 5)
5
-1
277
(Note 5)
273
275
257
1. Remove to numerical order (
1
to
5
) in the left figure.
DISASSEMBLY
1
#2 X 1 → #3 X 1
Left View
Left View
#2
#3
Bottom View
Left View
Left View
Top View
#3
#3
#3
#12
5
CM Radiation Sheet (
5
-1
) → #3 X 3 → Heat Sink (R)/ Lens Frame (R)(
5
-2
) → #12 X 2 → Heat Sink
(L)(381)/ Lens Frame (L)(381) (
5
-3
)
Screw
#1: M1.7 X 2.5
(Black)
2-635-562-11
2-635-562-11
2.5
1.7
#2: M1.7 X 4.0
(Black)
2-635-562-31
2-635-562-31
4.0
1.7
#3: M1.7 X 2.5
(Red)
2-660-401-01
2-660-401-01
2.5
1.7
2
#3 X 2
Bottom View
#3
3
#3 X 2
Bottom View
#3
4
#3 X 2
Left View
Right View
#3
#3
#12: M1.7 X 5.0 (Tapping)
(Black)
3-080-204-21
3-080-204-21
1.7
5.0
#172: M1.4 X 4.0 (Tapping)
(Black)
2-178-410-01
2-178-410-01
1.4
4.0
Note
Note 2: Refer to “Assembly-4: How to distinguish the side of Optical-
Filter Block facing to Lens Device”.
Note 2: Assembly-4: How to distinguish the side of Optical Filter
Block facing to Lens Device を参照してください。
Note 1: Be sure to read “Precautions for Replacement of Imager” on
page 6-1 of Level 3 when changing the image.r.
Note 1: イメージャの交換時はLevel 3の6-1ページ、 イメージャ交
換時の注意 を必ずお読みください。
Note 3: Install the thin filter to the lens device side, and install the
thick filter in the ASM module side.
Note 3: 薄いフィルタをレンズ側に、厚いフィルタをASM側に取り
付けてください。
Note 4: This model is provided with a flash unit using LED Flash/Video
light.
Therefore, the LED Flash/Video light does not have high volt-
age part and does not need to be discharged.
age part and does not need to be discharged.
Note 4: この機種ではLEDを使用したLEDフラッシュ /ビデオライト
を使用しております。
そのため高電圧部分が無く、放電は不要です。
Note 5: The CM Radiation Sheet, Radiation Sheet (AV) and Radiation
Sheet (CO) when peeling off once, so that it cannot be reused.
Note 5: CM Radiation SheetとRadiation Sheet (AV)とRadiation
Sheet (CO) 、は一度剥がすと粘着力が弱くなるため、再利
用はしないでください。
用はしないでください。
2-9
HDR-CX570E/CX580E/CX580V/CX580VE/CX590V/PJ580/PJ580E/PJ580V/PJ580VE/PJ590V/PJ600E/PJ600V/PJ600VE_L2
301
4-271-642-11
RING (381), LENS
302
A-1823-899-A CABINET (F) ASSY (381), SERVICE
303
4-271-948-01
EMBLEM (4.4), G
304
4-275-996-01
CUSHION (BM), MICROPHONE
305
4-271-649-01 CUSHION,
MICROPHONE
306
4-271-643-01 RETAINER,
MICROPHONE
307
A-1760-156-B BARRIER UNIT, LENS
308
4-271-647-01
PLATE, F GROUND
309
4-271-650-01 FRAME,
F
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
MIC901 1-542-856-11 MICROPHONE
UNIT
#1
2-635-562-11 SCREW
(M1.7)
#11
3-078-890-11 SCREW,
TAPPING
#12
3-080-204-21 SCREW,
TAPPING,
P2
2-1-7. FRONT PANEL SECTION
Screw
#1: M1.7 X 2.5
(Black)
2-635-562-11
2-635-562-11
2.5
1.7
#11: M1.7 X 4.0 (Tapping)
(Silver)
3-078-890-11
3-078-890-11
4.0
1.7
#12: M1.7 X 5.0 (Tapping)
(Black)
3-080-204-21
3-080-204-21
1.7
5.0
#1
MIC901
#11
#12
#12
#1
301
302
306
305
304
303
307
308
309
2-10
HDR-CX570E/CX580E/CX580V/CX580VE/CX590V/PJ580/PJ580E/PJ580V/PJ580VE/PJ590V/PJ600E/PJ600V/PJ600VE_L2
351
4-271-957-01
HOLDER (O (381)), JACK (Non HDD Model)
352
4-277-792-01
SHEET (AVR (381)), SHIELD (Non HDD Model)
353
A-1810-661-A FP-1323 BOARD, COMPLETE (Non HDD Model)
354
4-271-958-01
HOLDER (U (381)), JACK (Non HDD Model) (Note 2)
356
4-274-130-01
SHEET (BT), SHIELD
357
A-1852-720-A MS-478 BOARD, COMPLETE (SERVICE)
358
4-265-547-01
GASKET UA (Non HDD Model)
359
4-271-962-01 GASKET
(MS)
360
4-265-602-01 FRAME,
BT
361
4-265-603-01 PANEL,
BT
362
4-265-606-01
SPRING, BT LOCK
363
4-265-605-01 LOCK,
BT
364
4-265-610-01 TALLY,
MS
365
4-265-609-01
CLAW, BT RETAINER
366
4-265-604-01 SLOT,
MS
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
367
4-265-611-01
PLATE (MS), GROUND
368
4-298-888-01
COVER (378), MS
369
4-265-607-02 LID,
MS
370
4-271-950-01
HOLDER (O (389)), JACK (HDD Model)
371
A-1810-660-A FP-1321 FLEXIBLE BOARD, COMPLETE (HDD Model)
372
4-271-951-01
HOLDER (U (389)), JACK (HDD Model) (Note 2)
BH8001 1-251-928-21
HOLDER, BATTERY (Note 1)
BT8001 1-756-135-31
BATTERY LITHIUM SECONDARY (Note 1)
J901
1-842-658-31
JACK, DC (Non HDD Model)
J901
1-842-658-41
JACK, DC (HDD Model)
#1
2-635-562-11 SCREW
(M1.7)
#3
2-660-401-01
SCREW (M1.7), NEW TRU-STAR, P2
#11
3-078-890-11 SCREW,
TAPPING
#12
3-080-204-21 SCREW,
TAPPING,
P2
2-1-8. BATTERY PANEL SECTION
ns : not supplied
Screw
#1: M1.7 X 2.5
(Black)
2-635-562-11
2-635-562-11
2.5
1.7
#3: M1.7 X 2.5
(Red)
2-660-401-01
2-660-401-01
2.5
1.7
#11: M1.7 X 4.0 (Tapping)
(Silver)
3-078-890-11
3-078-890-11
4.0
1.7
#12: M1.7 X 5.0 (Tapping)
(Black)
3-080-204-21
3-080-204-21
1.7
5.0
Note
Caution:
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
Note 1: Replace the battery holder (BH8001) together when
replacing the lithium storage battery (BT8001) on the
MS-478 board. (The battery holder removed once
MS-478 board. (The battery holder removed once
cannot be usedagain.)
When mounting these parts, mount new battery holder
first and attach new lithium storage battery next.
first and attach new lithium storage battery next.
Note 1: MS-478基板のリチウム蓄電池 (BT8001) を交換する場合は
バッテリホルダ (BH8001) も同時に新品に交換してくださ
い。
い。
(一度使用したバッテリホルダは再使用できません。)
部品取り付けの際は、先にバッテリホルダを取り付けてか
らリチウム蓄電池を装着してください。
らリチウム蓄電池を装着してください。
注意 :
電池の交換は、正しく行わないと破裂する恐れがあります。
電池を交換する場合には必ず同じ型名の電池又は同等品と交換して
ください。
使用済み電池は、取扱指示に従って処分してください。
電池を交換する場合には必ず同じ型名の電池又は同等品と交換して
ください。
使用済み電池は、取扱指示に従って処分してください。
Note 2: Refer to "Assembly-5: Installation Cautions of the DC
Jack Harness.".
Note 2: Assembly-5: Installation Cautions of the DC Jack Harness.
を参照してください。
MS-478
Non HDD Model
Non HDD
Model
Model
HDD Model
BH8001
(Note 1)
(Note 1)
ns
#1
#3
357
351
354
(Note 2)
360
361
365
358
359
364
366
362
363
368
369
367
#11
#12
353
352
356
J901
BT8001
(Note 1)
(Note 1)
: BT8001 (LITHIUM RECHARGEABLE BATTERY)
Board on the mount position.
(See page 6-42 of Level 3)
Board on the mount position.
(See page 6-42 of Level 3)
370
372
(Note 2)
#11
371
356
J901
Click on the first or last page to see other HDR-CX570E / HDR-CX580E / HDR-CX580V / HDR-CX580VE / HDR-CX590V / HDR-PJ580 / HDR-PJ580E / HDR-PJ580V / HDR-PJ580VE / HDR-PJ590V / HDR-PJ600 / HDR-PJ600E / HDR-PJ600V / HDR-PJ600VE (serv.man2) service manuals if exist.