DOWNLOAD Sharp R-654M (serv.man12) Service Manual ↓ Size: 1.52 MB | Pages: 48 in PDF or view online for FREE

Microwave 100P cooking

Grill cooking

Dual grilling

with Microwave 50 P

with Microwave 30 P and 10 P

STANDARD TIME
40 MINUTES
45 MINUTES

Grill 10 MINUTES
Grill 45 MINUTES

43

Website: http://www.sharp.co.uk/support

Help Line: 08705 274277 (office hours)

When oven is working, air circulates within the cavity. The door does not form an
airtight seal so air may escape from the door.

The oven cavity will normally be colder than the food being cooked, and so steam
produced when cooking will condense on the colder surface. The amount of steam
produced depends on the water content of the food being cooked. Some foods,
such as potatoes have a high moisture content. Condensation trapped in the door
glass should clear after a few hours.

Arcing will occur when a metallic object comes into close proximity to the oven cavity
during cooking. This may possibly roughen the surface of the cavity, but would not
otherwise damage the oven. 

Ensure all “eyes” are removed and stand directly onto the turntable or in a heat
resistant flan dish or similar.

Check the door is closed properly.

Ensure correct power level has been selected.

The microwave energy pulses ON/OFF during cooking/defrosting.

The cabinet may become warm to the touch - keep children away.

Outer cabinet is hot.

Draught circulates around
the door.

Flashing or arcing from
within the cavity when
cooking.
Arcing potatoes.

After setting the time, the
oven does not start.

Oven cooks too slowly.

Oven makes a noise.

Condensation forms in the
oven, and may drip from
the door.

The wires in the mains cable are colour coded as
shown opposite:

As the colours of the cores in the mains lead of your
oven may not correspond with the coloured marking
identifying the terminals in your plug, connect the wires
as shown:
Make sure the terminal screws are tight and the cable is
held securely by the cable grip where it enters the plug.
Like most appliances in your home, your oven must be
connected to a single phase  230-240 Volt, 50Hz
alternating current supply.
If you do not make the proper electrical connections you
might damage the oven or injure yourself.  Neither
SHARP nor the supplier will be liable if this happens. 

green and yellow stripes =

blue

=

brown

=

• The green and yellow wire to the plug terminal

marked E or

or coloured green or coloured

green and yellow.

• The blue wire to the plug terminal marked N or

coloured black or coloured blue.

• The brown wire to the plug terminal marked L or

coloured red or coloured brown.

NOTE:
If you cook food for more than the standard time 
(see chart opposite) on the same cooking mode, the
oven’s safety mechanisms will automatically activate.
The microwave power level will be reduced or the
grill heating elements will turn on and off.

R-654M O/M & C/B  07/02/2001  08:36  Page 43

44

Website: http://www.sharp.co.uk/support

Help Line: 08705 274277 (office hours)

Subject to the conditions listed below, SHARP
Electronics (U.K.) Ltd (hereafter called “the Company”),
guarantee to provide for the repair of, or, at its option
replace this SHARP equipment, or any component
thereof, (other than Glass Turntables), which is faulty or
below standard, as a result of inferior workmanship or
materials.

The conditions of the Guarantee: 
1 This Guarantee shall only apply to defects or faults

which are notified to the Company, or its Service
Technician appointed by Sharp, within one year
from the date of purchase of the equipment,
provided that this Guarantee shall extend for a
further period of one year in respect of microwave
oven magnetron parts only.

2 This Guarantee covers equipment intended for

private domestic use only. This oven is suitable for
domestic food preparation and is not designed for
commercial, industrial or laboratory use. This
Guarantee does not apply to equipment used in the
course of a business, trade or profession.  Only use
the microwave oven for cooking, defrosting or
reheating of food. SHARP declines any liability for
damages caused by improper use.

3 This Guarantee does not cover any faults or defects

caused by accident, misuse, fair wear and tear,
neglect, tampering with the equipment, or any
attempt at adjustment or repair other than by a
Service Technician Appointed by Sharp.  

4 Please clean your microwave oven regularly and

remove any stains or  fat  residues without delay.
Failure to do this may affect the quality and safety of
the product or prejudice your guarantee.

5 In the unlikely event of your equipment requiring

repair, please contact the dealer or supplier from
whom it was purchased.  You will need to provide
proof of date of purchase to the repairing company.
Please keep your invoice or receipt, which is
supplied at the time of purchase. Where it is not
possible to contact the dealer or supplier from whom
the oven was purchased, please contact the
telephone number given below.  You will then be
given details of how to obtain service.

Telephone: 08705 274277 (office hours)

6 This Guarantee is offered as an additional benefit to

the consumer’s statutory rights and  does not affect
these rights in any way.

SHARP parts and accessories have been specifically
designed for SHARP Microwaves.

No liability can be accepted for any inaccuracies or
omissions in this publication, although every possible
care has been taken to make it as complete and
accurate as possible.

• For general information & assistance with oven

queries, please contact our 
Customer Information Centre:
U.K.:

08705 274277 (office hours)

Ireland:

01 676 0648 (office hours)

Website: http://www.sharp.co.uk/support

• Replacement accessories may be obtained from our

main parts distributor Willow Vale Electronics Ltd.
Telephone:  0121 766 5414

• If you are unable to resolve a problem using the

checks covered on the last few pages, do not
attempt to service this microwave oven
yourself.

• Contact the dealer or supplier from whom the oven

was purchased in order to obtain service. Where this
is not possible, please contact the SHARP Customer
Information Centre, telephone: 
08705 274277 (office hours).

R-654M O/M & C/B  07/02/2001  08:36  Page 44

45

Website: http://www.sharp.co.uk/support

Help Line: 08705 274277 (office hours)

AC Line Voltage  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Single phase 230-240 V, 50 Hz
Power Consumption:
Microwave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.25 kW
Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.05 kW
Microwave/Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2.25 kW
Input Current:
Microwave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5.5 A 
Output power:
Microwave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .800 W (IEC 60705)
Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1000 W
MAFF heating category . . . . . . . . . . . . . . . . . . . . . . . . .E
Microwave frequency  . . . . . . . . . . . . . . . . . . . . . . . . . .2450 MHz
Outside Dimensions  . . . . . . . . . . . . . . . . . . . . . . . . . . .449(W) x 282(H) x 388(D) mm
Cavity Dimensions  . . . . . . . . . . . . . . . . . . . . . . . . . . . .290(W) x 194(H) x 313(D) mm
Oven capacity  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 litres
Cooking uniformity  . . . . . . . . . . . . . . . . . . . . . . . . . . . .Turntable diameter (272mm)
Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Approx. 14kg

This oven complies with the requirements of
Directives 89/336/EEC and 73/23/EEC as
amended by 93/68/EEC.

As part of a policy of continuous improvement, we
reserve the right to alter design and specification
without notice.

No part of this publication may be reproduced,
stored in a retrieval system or transmitted in any
form, electronically, mechanically, photocopied,
recorded, translated or other means without prior
permission from SHARP Electronics (U.K.) Ltd.

The illustrations, technical information and data
contained in this publication to our best
knowledge, were correct at the time of going to
print.  The right to change  specifications,  at any
time, without notice, is reserved as part of our
policy of continuous development and
improvement.

R-654M O/M & C/B  08/02/2001  13:03  Page 45

Manchester, U. K.

U.K.: 08705 274277 (office hours)

Ireland: 01 676 0648 (office hours)

Website: http://www.sharp.co.uk/support

PRINTED IN THE UK 

TINS-A258URR0

100% of the pulp used

in making this paper comes

from sustainable forests

R-654M O/M & C/B  08/02/2001  12:29  Page 46