Sony KDL-40NX720 / KDL-46NX720 / KDL-55NX720 / KDL-60NX720 Service Manual ▷ View online
KDL-40NX720/46NX720/55NX720/60NX720 3
SECTION 1 - SAFETY AND FEATURES
HANDLING THE LVDS FFC CONNECTOR
Several 2011 Models use a LVDS FFC Connector from the main board to the TCON Board. There are the three different
types of connectors that are used.
Refer to the following instructions when disconnecting and connecting these connectors.
DISCONNECTING THE LVDS FFC CONNECTOR
CAUTION:
Use caution when you connecting or removing the LVDS FFC Connector.
1. Gently press down on the release tabs of the connector slot.
DO NOT remove the connector by the reinforcement tab only.
2. Holding onto the entire LVDS FFC Connector, pull out the connector while continuing to hold down the release tabs of the
connector slot.
Correct
Incorrect
䐠
Press down
Main Board
Reinforcement
Tab
䐠
Press down
Main Board
Reinforcement
Tab
䐠
Reinforcement
Tab
Press down
Main Board
Connector Type 1
Connector Type 2
Connector Type 3
KDL-40NX720/46NX720/55NX720/60NX720 4
SECTION 1 - SAFETY AND FEATURES
CONNECTING THE LVDS FFC CONNECTOR
CAUTION:
The LVDS FFC Connector can be inserted into the Main Board upside down. If it is inserted upside down, the pins on the
LVDS FFC Connector will short-circuit and damage the board.
1. Holding onto the entire LVDS FFC Connector, insert the LVDS FFC Connector into the connector slot.
Inserted Correctly
Inserted Incorrectly
Main Board
Reinforcement
Tab
Main Board
Reinforcement
Tab
Main Board
Reinforcement
Tab
Connector Type 1
Connector Type 2
Connector Type 3
KDL-40NX720/46NX720/55NX720/60NX720 5
SECTION 1 - SAFETY AND FEATURES
SPECIAL HANDLING INSTRUCTIONS WHEN REPLACING THE LCD PANEL ASSEMBLY
Use the following precautionary guidelines when handling the LCD Panel Assembly to avoid material degradation or screen coating degradation.
1. After removing the boards and connectors, note where the frame is on the panel. (Figure 1)
2. Lift the LCD Panel Assembly by holding the top and bottom of the panel approximately 200mm from the edge with your palms
on the back of the panel. (Figure 2)
CAUTION: Lifting or holding the panel at the corners may damage the panel.
3. Use the same method when taking the replacement panel out of the carton. (Figure 3)
Figure 1
Figure 2
Figure 3
CAUTION: DO NOT lift the LCD Panel by holding the short side of the panel or by placing your palms on the front glass. (Figures 4 & 5)
Figure 4
Figure 5
KDL-40NX720/46NX720/55NX720/60NX720 6
SECTION 1 - SAFETY AND FEATURES
WARNINGS AND CAUTIONS - FRENCH
ATTENTION!!
Ces instructions de service sont à l’usage du personnel de service qualifié seulement. Pour prévenir le risque de choc électrique, ne pas faire
l’entretien autre que celui contenu dans le Mode d’emploi à moins que vous soyez qualifié faire ainsi.
POUR TRANSPORTER LE TÉLÉVISEUR
• T ransportez le téléviseur avec le nombre de personnes approprié ; un téléviseur de grande
taille doit être transporté par au moins deux personnes.
• Lors du transport du téléviseur , l’emplacement des mains est très important pour votre
sécurité, ainsi que pour éviter de causer des dommages.
ALERTE!!
Afin d’eviter tout risque d’electrocution provenant d’un chássis sous tension, un transformateur d’isolement doit etre utilisé lors de tout dépannage.
Le chássis de ce récepteur est directement raccordé à l’alimentation du secteur.
!
ATTENTION AUX COMPOSANTS RELATIFS A LA SECURITE!!
Les composants identifies par une trame et par une marque
!
sur les schemas de principe, les vues explosees et les listes de pieces sont
d’une importance critique pour la securite du fonctionnement. Ne les remplacer que par des composants Sony dont le numero de piece est
indique dans le present manuel ou dans des supplements publies par Sony. Les reglages de circuit dont l’importance est critique pour la securite
du fonctionnement sont identifies dans le present manuel. Suivre ces procedures lors de chaque remplacement de composants critiques, ou
lorsqu’un mauvais fonctionnement suspecte.
Click on the first or last page to see other KDL-40NX720 / KDL-46NX720 / KDL-55NX720 / KDL-60NX720 service manuals if exist.