DOWNLOAD Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Service Manual ↓ Size: 8.64 MB | Pages: 124 in PDF or view online for FREE

Model
RM-PJ2 RM-PJM12 VPL-CS5A VPL-CS6 VPL-CX6 VPL-EX1
Pages
124
Size
8.64 MB
Type
PDF
Document
Service Manual
Brand
Device
Projector
File
rm-pj2-rm-pjm12-vpl-cs5a-vpl-cs6-vpl-cx6-vpl-ex1.pdf
Date

Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Service Manual ▷ View online

DATA PROJECTOR
VPL-CS5A
VPL-CS6
VPL-CX6
VPL-EX1
REMOTE CONTROLLER
RM-PJ2
RM-PJM12
SERVICE MANUAL
1st Edition
VPL-CS5A/CS6/CX6/EX1
!
 WARNING
This manual is intended for qualified service personnel only.
To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that
contained in the operating instructions unless you are qualified to do so. Refer all servicing to
qualified service personnel.
!
 WARNUNG
Die Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.
Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um die
Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei
Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben
Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung
dazu besitzen.
!
 AVERTISSEMENT
Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin
de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les
réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.
Pour toute réparation faire appel à une personne compétente uniquement.
WARNING!!
AN INSULATED TRANSFORMER SHOULD BE USED DURING
ANY SERVICE TO AVOID POSSIBLE SHOCK HAZARD, BE-
CAUSE OF LIVE CHASSIS.
THE CHASSIS OF THIS RECEIVER IS DIRECTLY CONNECTED
TO THE AC POWER LINE.
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY A 
!
!
!
!
!
 MARK ON THE SCHEMATIC
DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE
CRITICAL TO SAFE OPERATION. REPLACE THESE COMPO-
NENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR
AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
ATTENTION!!
AFIN D’ÉVITER TOUT RISQUE D’ÉLECTROCUTION
PROVENANT D’UN CHÂSSIS SOUS TENSION, UN
TRANSFORMATEUR D’ISOLEMENT DOIT ETRE UTILISÉ LORS
DE TOUT  DÉPANNAGE.
LE CHÂSSIS DE CE RÉCEPTEUR EST DIRECTEMENT
RACCORDÉ Á L’ALIMENTATION SECTEUR.
ATTENTION AUX COMPOSANTS RELATIFS Á LA
SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MAPQUE 
!
!
!
!
!
 SUR
LES SCHÉMAS DE PRINCIPE, LES VUES EXPLOSÉES ET LES
LISTES DE PIECES SONT D’UNE IMPORTANCE CRITIQUE
POUR LA SÉCURITÉ DU FONCTIONNEMENT. NE LES
REMPLACER QUE PAR DES COMPOSANTS SONY DONT LE
NUMÉRO DE PIÈCE EST INDIQUÉ DANS LE PRÉSENT MANUEL
OU DANS DES SUPPLÉMENTS PUBLIÉS PAR SONY.
VPL-CS5A/CS6/CX6/EX1
For the customers in the Netherlands
Voor de klanten in Nederland
Hoe u de batterijen moet verwijderen, leest u in de tekst
van deze handleiding.
Gooi de batterij niet weg maar lever deze in als klein
chemisch afval (KCA).
Für Kunden in Deutschland
Entsorgungshinweis: Bitte werfen Sie nur entladene
Batterien in die Sammelboxen beim Handel oder den
Kommunen. Entladen sind Batterien in der Regel dann,
wenn das Gerät abschaltet und signalisiert “Batterie
leer” oder nach längerer Gebrauchsdauer der Batterien
“nicht mehr einwandfrei funktioniert”. Um
sicherzugehen, kleben Sie die Batteriepole z.B. mit
einem Klebestreifen ab oder geben Sie die Batterien
einzeln in einen Plastikbeutel.
1 (P)
1
VPL-CS5A/CS6/CX6/EX1
Table of Contents
1. Service Overview
1-1.
Appearance Figure ...................................................................................... 1-1
1-2.
Board Locations .......................................................................................... 1-1
1-3.
Disassembly ................................................................................................ 1-2
1-3-1.
Top Panel Assy Removal ........................................................... 1-2
1-3-2.
Side Panel Assy and L, NR, H2, Q Boards Removal ................ 1-2
1-3-3.
Power Block (Lamp) Removal ................................................... 1-3
1-3-4.
DC Fan Removal ........................................................................ 1-3
1-3-5.
Lens Gear Removal .................................................................... 1-4
1-3-6.
Speaker Assy and DC Fan (Sirocco) Removal .......................... 1-4
1-3-7.
C Board Removal ....................................................................... 1-5
1-3-8.
MSC and MS (VPL-CX6) Boards Removal .............................. 1-5
1-3-9.
GA and GB Boards Removal ..................................................... 1-6
1-3-10. Opt Unit Assy and Lamp Assy Removal ................................... 1-7
1-3-11. PS Con Aperture (VPL-EX1) and S In-polarizer (R), (G), (B)
Removal ..................................................................................... 1-7
1-3-12. Projection Lens Assy, Lamp Duct Assy and
U Board Removal ....................................................................... 1-8
1-3-13. S Prism Block Assy and
S Out-pre-polarizer (R), (G), (B) Removal ................................ 1-9
1-3-14. DC Fan (Sirocco) and V Board Removal ................................ 1-10
1-3-15. S Board Removal ..................................................................... 1-11
1-3-16. Extension Board and Extension Connectors ............................ 1-12
1-3-17. Extension Board and Extension Connectors Connection ......... 1-13
1-3-18. Warning on Power Connection ................................................ 1-14
2. Electrical Adjustments
2-1.
Preparation .................................................................................................. 2-1
2-1-1.
Required Equipment ................................................................... 2-1
2-1-2.
Opt Unit Adjustment .................................................................. 2-1
2-1-3.
How to Enter the Factory Mode ................................................. 2-2
2-2.
V COM Adjustment .................................................................................... 2-2
2-3.
Initial Values of Adjustment Items ............................................................. 2-3
2-4.
Service Know-How ................................................................................... 2-11
2-4-1.
When the S Prism Block Is Replaced ...................................... 2-11
2-4-2.
When the C Board Is Replaced ................................................ 2-11
2-4-3.
When the Adjuster Assy Is Returned
by the Emergency Mode .......................................................... 2-11
2-5.
White Balance Adjustment ....................................................................... 2-12
2-5-1.
HIGH Mode of INPUT-A ........................................................ 2-12
2-5-2.
LOW Mode of INPUT-A ......................................................... 2-12
2-5-3.
HIGH Mode of VIDEO ............................................................ 2-12
2-5-4.
LOW Mode of VIDEO ............................................................. 2-12
2-6.
Memory Structure ..................................................................................... 2-13
Page of 124
Display

Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Service Manual ▷ Download

  • DOWNLOAD Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Service Manual ↓ Size: 8.64 MB | Pages: 124 in PDF or view online for FREE
  • Here you can View online or download the Service Manual for the Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 in PDF for free, which will help you to disassemble, recover, fix and repair Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Projector. Information contained in Sony RM-PJ2 / RM-PJM12 / VPL-CS5A / VPL-CS6 / VPL-CX6 / VPL-EX1 Service Manual (repair manual) includes:
  • Disassembly, troubleshooting, maintenance, adjustment, installation and setup instructions.
  • Schematics, Circuit, Wiring and Block diagrams.
  • Printed wiring boards (PWB) and printed circuit boards (PCB).
  • Exploded View and Parts List.