DOWNLOAD Sony SPK-HCC Service Manual ↓ Size: 211.07 KB | Pages: 6 in PDF or view online for FREE

Model
SPK-HCC
Pages
6
Size
211.07 KB
Type
PDF
Document
Service Manual
Brand
Device
Movie
File
spk-hcc.pdf
Date

Sony SPK-HCC Service Manual ▷ View online

Sony EMCS Co.
SPK-HCC
SPK-HCC
SPORTS PACK
SERVICE MANUAL
Material
Plastic (PC, ABS), glass
Waterproof
O-ring, buckles
Built-in microphone
Stereo
Dimension
Approx. 159 
×
 148 
×
 220 mm (w / h / d) (xx 
×
 xx  
×
 xx inches)
Mass
Approx. 960 g (xx lb xx oz) (only sports pack)
Included items
Sports pack (1), Shoulder strap (1), Camera mounting shoe (A (1)/B
(1)/C (1)/D(1)/E(1)
/F(1)
), Tripod screw plate (1), Reflex prevention
ring (Ø 25 (1)/M30 
×
 Ø 62 (1)/M30 
×
 Ø 43 (1)/M37 
×
 Ø 55 (1)), Grease
(1), Spacer (1), Anti-fogging lens solution (1),
Desiccant (1), Set of printed documentation
Design and specifications subject to change without notice.
SPECIFICATIONS
• This Sports Pack SPK-HCC is exclusively for use with the Sony
digital video camera recorder
HDR-CX7/CX-6,
HDR-SR8/SR7/SR5,
HDR-UX7/UX5/UX3,
HDR-HC7/HC5/HC3,
DCR-SR300/SR290/SR200/SR190/SR100/SR90/SR82/SR72/
SR62/SR52/SR42/
SR33/
SR32,
DCR-DVD908/DVD905/DVD808/DVD805/DVD803/DVD755/
DVD708/DVD705/DVD703/DVD653/DVD608/DVD605/DVD602/
DVD508/DVD506/DVD505/DVD408/DVD406/DVD405/DVD404/
DVD403/DVD308/DVD306/DVD305/DVD304/DVD205/DVD203/
DVD202/DVD109/DVD108/DVD106/DVD105/DVD103/DVD92,
DCR-HC96/HC94/HC90/HC48/HC47/HC46/HC45/HC44/HC43/
HC42/HC41/HC39/HC38/HC37/HC36/HC35/HC33/HC32/HC28/
HC27/HC26/HC24/HC23/HC22/HC21/HC19/HC17
• The sports pack SPK-HCC is water- and moisture- resistant, making
it possible to use the Sony digital video camera recorder (referred to
below as “video camera”).
• Usable at the depth as low as 5 meters (17 feet) under water.
• For using your video camera with this pack, refer to the operating
instructions of the video camera.
• Before you start recording, make sure that the video camera is
working correctly and there is no water leakage.
• Sony does not accept liability for damage to the video camera,
battery, etc., when using the sports pack or for the cost of
recording if water leakage occurs as a result of incorrect use.
MAIN FEATURE
2007H0800-1
  ©2007.08
Published by Kohda TEC
9-852-161-12
US Model
Canadian Model
AEP Model
Ver. 1.1  2007.08
The changed portions from
Ver. 1.0 are shown in blue.
Revised-1
Replace the previously issued
SERVICE MANUAL 9-852-161-11
with this Manual.
— 2 —
SPK-HCC
TABLE OF CONTENTS
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 
0
 OR DOTTED LINE WITH
MARK 
0
 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 
0
 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
1.
Check the area of your repair for unsoldered or poorly-soldered
connections.  Check the entire board surface for solder splashes
and bridges.
2.
Check the interboard wiring to ensure that no wires are
"pinched" or contact high-wattage resistors.
3.
Look for unauthorized replacement parts, particularly
transistors, that were installed during a previous repair.  Point
them out to the customer and recommend their replacement.
4.
Look for parts which, through functioning, show obvious signs
of deterioration.  Point them out to the customer and
recommend their replacement.
5.
Check the B+ voltage to see it is at the values specified.
6.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
REPAIR PARTS LIST
EXPLODED VIEWS
1.
OVERALL SECTION ·························································· 3
2.
FRONT CASE SECTION ···················································· 4
3.
ACCESSORIES LIST ··························································· 5
— 3 —
SPK-HCC
REPAIR PARTS LIST
EXPLODED VIEWS
NOTE:
-XX, -X mean standardized parts, so they may
have some differences from the original one.
Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
The mechanical parts with no reference number
in the exploded views are not supplied.
1. OVERALL SECTION
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
(Note 1) When putting grease the main O-ring (Ref. No. 3),
always use the grease of the blue tube of the accessory.
When using the grease of the yellow tube and the grease of
the other Inc., it hurts the main O-ring and it causes the water
leakage.
Note :
The marked  “
0
”    are parts in
relation to waterproof.
Replace these components with
Sony parts.
Be sure to check up waterproof
after repair.
Note :
La 
0
 marquée sont des pièces par
rapport à imperméable à l’ eau.
Ne les remplacer que par une
pièce portant le numéro spécifié.
Soyez sûr de vérifier vers le haut
d’ imperméable à l’ eau après la
réparation.
ns : not supplied
1
1
2
3
4
5
6
7
13
9
9
9
9
10
12
14
15
16
17
18
19
20
21
23
22
8
11
ns
ns
ns
(Note 1)
(See page 4)
1
2-580-983-01 SHAFT, HINGE
2
3-098-142-01 CASE, REAR
0 3
2-668-985-01
O RING, MAIN (Note 1)
4
A-1244-463-A HOOD ASSY, MIRROR
5
2-580-955-01 MIRROR
6
2-580-954-01 HOOD, MIRROR
7
2-580-969-01 SHAFT, BUCKLE
8
2-589-138-01 RETAINER, GRIP
9
3-076-866-01 BIND (2X6), TAPPING SCREW
10
A-1105-402-A GRIP BELT ASSY
11
2-634-715-01 TUBE, GRIP BELT
12
2-580-957-01 BUCKLE
13
3-951-813-11 SCREW (2X6) (TYPE 2), +K
0 14
3-073-881-01 CAP (RED), AIR PUNCHING
15
2-580-959-01 KNOB, BUCKLE SLIDER
16
2-589-297-01 LOCK, BUCKLE
17
2-589-298-01 SPRING, BUCKLE LOCK
18
2-593-190-01 SLIDER (LOWER), BUCKLE
19
2-651-030-01 SPRING, SLIDER
20
2-580-958-01 SLIDER, BUCKLE
21
2-580-961-01 PLATE, BUCKLE RETAINER
22
3-052-424-01 SHAFT, GRIP
23
2-580-956-01 SHAFT, MIRROR HINGE
Ver. 1.1  2007.08
The changed portions from
Ver. 1.0 are shown in blue.
— 4 —
SPK-HCC
2. FRONT CASE SECTION
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
51
3-076-866-01 BIND (2X6), TAPPING SCREW
52
A-1175-085-A SPK-001 MOUNT (Note 2)
53
2-668-979-01 BOX, CONTROL
54
     (Note 1)
HIMERON
* 55
3-959-469-01 PLATE, TRIPOD SCREW
56
3-091-040-01 SCREW (2.6X6), TAPPING
57
2-668-974-01 LENS (WINDOW RETAINER)
58
2-668-987-01 GLASS, LENS WINDOW
0 59
2-668-986-01 PACKING, LENS WINDOW (Note 3)
0 60
A-1244-464-A FRONT CASE ASSY
0 61
A-7095-209-A MICROPHONE BLOCK ASSY
62
2-668-980-01 LIGHT, GUIDE,
63
2-342-952-01 SCREW (1.7X4 #0-1), TP
64
2-668-977-01 COVER, MICROPHONE
65
2-668-992-01 SHEET, INDICATION
66
3-098-139-01 COVER, CONTROL
67
1-830-399-21 CORD, CONNECTION (AV MULTIPLE)
68
A-1174-862-A BASE (A) BLOCK ASSY
69
X-2048-702-1 BASE ASSY, SCREW
70
2-593-204-01 LABEL, TEMPERATURE CAUTION
71
2-668-975-01 COVER, LENS WINDOW
72
2-668-993-01 COVER, CODE
ns : not supplied
(Note 2) In this model, parts are exchange in order to repair only the
mounted board.
Note :
The marked  “
0
”    are parts in
relation to waterproof.
Replace these components with
Sony parts.
Be sure to check up waterproof
after repair.
Note :
La 
0
 marquée sont des pièces par
rapport à imperméable à l’ eau.
Ne les remplacer que par une
pièce portant le numéro spécifié.
Soyez sûr de vérifier vers le haut
d’ imperméable à l’ eau après la
réparation.
(Note 3) When putting grease the lens window packing (Ref. No. 59),
always use the grease of the blue tube of the accessory.
When using the grease of the yellow tube and the grease of the
other Inc., it hurts the lens window packing and it causes the
water leakage.
SPK
-001
51
52
53
55
56
70
57
58
59
65
60
62
51
51
67
68
69
51
71
ns
ns
ns
(Note 3)
51
51
66
61
51
64
63
72
(SIZE : 12mm 
×
 38mm)
54
(Note 2)
(SIZE : 6mm 
×
 9mm)
54
(Note 1)
(Note 1)
(Note 1) For the part of 54: HIMERON, Cut the NON WOVEN (T0.25)
(3-076-631-01) for specified size.
Page of 6
Display

Sony SPK-HCC Service Manual ▷ Download

  • DOWNLOAD Sony SPK-HCC Service Manual ↓ Size: 211.07 KB | Pages: 6 in PDF or view online for FREE
  • Here you can View online or download the Service Manual for the Sony SPK-HCC in PDF for free, which will help you to disassemble, recover, fix and repair Sony SPK-HCC Movie. Information contained in Sony SPK-HCC Service Manual (repair manual) includes:
  • Disassembly, troubleshooting, maintenance, adjustment, installation and setup instructions.
  • Schematics, Circuit, Wiring and Block diagrams.
  • Printed wiring boards (PWB) and printed circuit boards (PCB).
  • Exploded View and Parts List.