Sony DVP-NS601HP / DVP-NS700H / DVP-NS700HP / DVP-NS707HP / DVP-NS708H / DVP-NS708HP Service Manual ▷ View online
– 5 –
DVP-NS601HP/NS700H/NS700HP/NS707HP/NS708H/NS708HP
6.
TEST MODE
6-1.
Executing IOP Measurement .............................................. 6-1
6-2.
Emergency History Check ................................................... 6-1
6-3.
Initializing Setup Data .......................................................... 6-2
6-4.
Version Information ............................................................. 6-3
6-5.
If Con Self Diagnostic Function .......................................... 6-3
7.
ELECTRICAL ADJUSTMENT
7-1.
Power Supply Output Voltage Check ................................. 7-1
7-2.
Adjustment of Video System ............................................... 7-2
8.
REPAIR PARTS LIST
8-1.
Exploded Views ................................................................... 8-1
8-1-1. Main Section ................................................................... 8-1
8-1-2. Mechanism Deck Assembly ........................................... 8-3
8-1-2. Mechanism Deck Assembly ........................................... 8-3
8-2.
Electrical Parts List .............................................................. 8-4
– 6 –
DVP-NS601HP/NS700H/NS700HP/NS707HP/NS708H/NS708HP
SERVICE NOTE
1. DISC REMOVAL PROCEDURE (at POWER OFF)
1) Open dust cover to access to a hole insert a tapering driver into the aperture of the unit bottom, and move the lever of chuck can in the
direction of the arrow A. (See Fig. 1)
2) Draw out the tray in the direction of the arrow B, and remove a disc. (See Fig. 1)
3) After removing the disc, push in the direction of arrow C until the tray fully in.
4) Move the lever of chuck cam in the direction of arrow D.
3) After removing the disc, push in the direction of arrow C until the tray fully in.
4) Move the lever of chuck cam in the direction of arrow D.
– 6E –
2. CHILD LOCK DISABLED PROCEDURE
When "LOCKED" appears on the front panel display, Child Lock is activated. In order to disable it, either
1) Press O RETURN, ENTER and then ?/1 on the remote when the player is in standby mode.
The player turns on and "UNLOCKED" appears on the front panel display; or
2) Disconnect the player from the wall outlet (AC power source).
Note:
i.
i.
Child Lock is set when you press O RETURN, ENTER, and then ?/1 on the remote during player in standby mode.
ii. The A and Z buttons on the player or the remote do not work while the Child Lock is set.
Tray
B
C
The lever of a chuck cam
Hole
A
D
1-1
DVP-NS601HP/NS700H/NS700HP/NS707HP/NS708H/NS708HP
2
WARNING
To reduce the risk of fire or
electric shock, do not expose
this apparatus to rain or
moisture.
To avoid electrical shock, do
not open the cabinet. Refer
servicing to qualified
personnel only.
The mains lead must only be
changed at a qualified
service shop.
Batteries or batteries
installed apparatus shall not
be exposed to excessive heat
such as sunshine, fire or the
like.
electric shock, do not expose
this apparatus to rain or
moisture.
To avoid electrical shock, do
not open the cabinet. Refer
servicing to qualified
personnel only.
The mains lead must only be
changed at a qualified
service shop.
Batteries or batteries
installed apparatus shall not
be exposed to excessive heat
such as sunshine, fire or the
like.
CAUTION
The use of optical instruments with
this product will increase eye
hazard. As the laser beam used in
this CD/DVD player is harmful to
eyes, do not attempt to disassemble
the cabinet.
Refer servicing to qualified
personnel only.
this product will increase eye
hazard. As the laser beam used in
this CD/DVD player is harmful to
eyes, do not attempt to disassemble
the cabinet.
Refer servicing to qualified
personnel only.
Disposal of Old Electrical &
Electronic Equipment
This symbol is applicable only in
the European Union and other
European countries with separate
collection systems.
Electronic Equipment
This symbol is applicable only in
the European Union and other
European countries with separate
collection systems.
Precautions
Safety
• The power requirements and
• The power requirements and
power consumption of this unit
are indicated on the back of the
unit. Check that the unit’s
operating voltage is identical
with your local power supply.
are indicated on the back of the
unit. Check that the unit’s
operating voltage is identical
with your local power supply.
• To prevent fire or shock hazard,
do not place objects filled with
liquids, such as vases, on the
apparatus.
liquids, such as vases, on the
apparatus.
Installing
• Do not install the unit in an
• Do not install the unit in an
inclined position. It is designed
to be operated in a horizontal
position only.
to be operated in a horizontal
position only.
• Keep the unit and discs away
from equipment with strong
magnets, such as microwave
ovens, or large loudspeakers.
magnets, such as microwave
ovens, or large loudspeakers.
• Do not place heavy objects on
the unit.
For Customers in Taiwan
only
only
Please recycle used batteries.
DVP–XXXX
00V 00Hz
00W
NO.
0-000-000-00
X
Power
requirements
and power
consumption
requirements
and power
consumption
m
Notes About the
Discs
Discs
• To keep the disc clean, handle
the disc by its edge. Do not touch
the surface. Dust, fingerprints, or
scratches on the disc may cause
it to malfunction.
the surface. Dust, fingerprints, or
scratches on the disc may cause
it to malfunction.
• Do not expose the disc to direct
sunlight or heat sources such as
hot air ducts, or leave it in a car
parked in direct sunlight as the
temperature may rise
considerably inside the car.
hot air ducts, or leave it in a car
parked in direct sunlight as the
temperature may rise
considerably inside the car.
• After playing, store the disc in its
case.
• Clean the disc with a cleaning
cloth. Wipe the disc from the
centre out.
centre out.
• Do not use solvents such as
benzine, thinner, commercially
available cleaners, or anti-static
spray intended for vinyl LPs.
available cleaners, or anti-static
spray intended for vinyl LPs.
• If you have printed the disc’s
label, dry the label before
playing.
playing.
5
About This Manual
• Instructions in this manual describe the controls on the remote. You can also use the controls
on the player if they have the same or similar names as those on the remote.
• “DVD” may be used as a general term for commercial DVDs, DVD+RWs/DVD+Rs/
DVD+Rs DL (+VR mode) and DVD-RWs/DVD-Rs/DVD-Rs DL (VR mode, video mode).
• The meaning of the icons used in this manual is described below:
Icons
Meaning
Functions available for commercial DVDs and DVD+RWs/DVD+Rs/DVD+Rs
DL in +VR mode or DVD-RWs/DVD-Rs/DVD-Rs DL in video mode
DL in +VR mode or DVD-RWs/DVD-Rs/DVD-Rs DL in video mode
Functions available for DVD-RWs/DVD-Rs/DVD-Rs DL in VR (Video
Recording) mode
Recording) mode
Functions available for VIDEO CDs (including Super VCDs or CD-Rs/CD-RWs
in video CD format or Super VCD format)
in video CD format or Super VCD format)
Functions available for music CDs or CD-Rs/CD-RWs in music CD format
Functions available for DATA CDs (CD-ROMs/CD-Rs/CD-RWs containing
MP3
MP3
*1
audio tracks, JPEG image files, and DivX
*2*3
video files)
Functions available for DATA DVDs (DVD-ROMs/DVD+RWs/DVD+Rs/DVD+Rs
DL/DVD-RWs/DVD-Rs/DVD-Rs DL containing MP3
DL/DVD-RWs/DVD-Rs/DVD-Rs DL containing MP3
*1
audio tracks, JPEG image
files, and DivX
*2*3
video files)
*1 MP3 (MPEG-1 Audio Layer III) is a standard format defined by ISO (International Organization for
Standardization)/IEC (International Electrotechnical Commission) MPEG which compresses audio data.
*2 DivX
®
is a video file compression technology, developed by DivX, Inc.
*3 DivX, DivX Certified, and associated logos are trademarks of DivX, Inc. and are used under license.
6
This Player Can Play the
Following Discs
Following Discs
“DVD+RW,” “DVD-RW,” “DVD+R,”
“DVD+R DL,” “DVD-R,” “DVD VIDEO,”
and “CD” logos are trademarks.
“DVD+R DL,” “DVD-R,” “DVD VIDEO,”
and “CD” logos are trademarks.
Note about CDs/DVDs
The player can play CD-ROMs/CD-Rs/
CD-RWs recorded in the following formats:
– music CD format
– video CD format
– MP3 audio tracks, JPEG image files, and
CD-RWs recorded in the following formats:
– music CD format
– video CD format
– MP3 audio tracks, JPEG image files, and
DivX video files of format conforming to
ISO 9660* Level 1/Level 2, or its extended
format, Joliet
ISO 9660* Level 1/Level 2, or its extended
format, Joliet
– KODAK Picture CD format
* A logical format of files and folders on
CD-ROMs, defined by ISO (International
Organization for Standardization).
Organization for Standardization).
The player can play DVD-ROMs/
DVD+RWs/DVD+Rs/DVD+Rs DL/
DVD-RWs/DVD-Rs/DVD-Rs DL recorded
in the following formats:
– MP3 audio tracks, JPEG image files, and
DVD+RWs/DVD+Rs/DVD+Rs DL/
DVD-RWs/DVD-Rs/DVD-Rs DL recorded
in the following formats:
– MP3 audio tracks, JPEG image files, and
DivX video files of format conforming to
UDF (Universal Disk Format).
UDF (Universal Disk Format).
Example of discs that the player
cannot play
cannot play
The player cannot play the following discs:
• CD-ROMs/CD-Rs/CD-RWs other than
• CD-ROMs/CD-Rs/CD-RWs other than
those recorded in the formats listed on this
page.
page.
• CD-ROMs recorded in PHOTO CD format.
• Data part of CD-Extras.
• DVD Audio discs.
• HD layer on Super Audio CDs.
• DATA DVDs that do not contain MP3
• Data part of CD-Extras.
• DVD Audio discs.
• HD layer on Super Audio CDs.
• DATA DVDs that do not contain MP3
audio tracks, JPEG image files, or DivX
video files.
video files.
• BDs.
• HD DVDs.
• Disc recorded with an AVCHD-compatible
• HD DVDs.
• Disc recorded with an AVCHD-compatible
DVD video camera.
Also, the player cannot play the following
discs:
• A commercial DVD with a different region
discs:
• A commercial DVD with a different region
code.
• A disc that has a non-standard shape (e.g.,
card, heart).
• A disc with paper or stickers on it.
• A disc that has the adhesive of cellophane
• A disc that has the adhesive of cellophane
tape or a sticker still left on it.
Region code
Your player has a region code printed on the
back of the unit and only will play
commercial DVDs (playback only) labelled
with identical region codes. This system is
used to protect copyrights.
back of the unit and only will play
commercial DVDs (playback only) labelled
with identical region codes. This system is
used to protect copyrights.
Commercial DVDs labelled
will also
play on this player.
If you try to play any other commercial DVD,
the message “Playback prohibited by area
limitations.” will appear on the TV screen.
Depending on the commercial DVD, there
may be no region code indication, even
though playing the commercial DVD is
prohibited by area restrictions.
the message “Playback prohibited by area
limitations.” will appear on the TV screen.
Depending on the commercial DVD, there
may be no region code indication, even
though playing the commercial DVD is
prohibited by area restrictions.
Format of discs
Commercial DVD
DVD-RW/-R
DVD+RW/+R/
+R DL
+R DL
VIDEO CD/
Music CD
Music CD
CD-RW/-R
ALL
DVP–XXXX
00V 00Hz
00W
NO.
0-000-000-00
X
Region code
3
Precautions
On safety
Should any solid object or liquid fall into the
cabinet, unplug the player and have it
checked by qualified personnel before
operating it any further.
Should any solid object or liquid fall into the
cabinet, unplug the player and have it
checked by qualified personnel before
operating it any further.
On power sources
• The player is not disconnected from the AC
• The player is not disconnected from the AC
power source (mains) as long as it is
connected to the wall outlet, even if the
player itself has been turned off.
connected to the wall outlet, even if the
player itself has been turned off.
• If you are not going to use the player for a
long time, be sure to disconnect the player
from the wall outlet. To disconnect the AC
power cord (mains lead), grasp the plug
itself; never pull the cord.
from the wall outlet. To disconnect the AC
power cord (mains lead), grasp the plug
itself; never pull the cord.
On placement
• Place the player in a location with adequate
• Place the player in a location with adequate
ventilation to prevent heat build-up in the
player.
player.
• Do not place the player on a soft surface
such as a rug.
• Do not place the player in a location near
heat sources, or in a place subject to direct
sunlight, excessive dust, or mechanical
shock.
sunlight, excessive dust, or mechanical
shock.
• Do not install this player in a confined
space, such as a bookshelf or similar unit.
• Install the player so that the AC power cord
(mains lead) can be unplugged from the
wall socket immediately in the event of
trouble.
wall socket immediately in the event of
trouble.
On operation
• If the player is brought directly from a cold
• If the player is brought directly from a cold
to a warm location, or is placed in a very
damp room, moisture may condense on the
lenses inside the player. Should this occur,
the player may not operate properly. In this
case, remove the disc and leave the player
turned on for about half an hour until the
moisture evaporates.
damp room, moisture may condense on the
lenses inside the player. Should this occur,
the player may not operate properly. In this
case, remove the disc and leave the player
turned on for about half an hour until the
moisture evaporates.
• When you move the player, take out any
discs. If you don’t, the disc may be
damaged.
damaged.
On adjusting volume
Do not turn up the volume while listening to
a section with very low level inputs or no
audio signals. If you do, the speakers may be
damaged when a peak level section is played.
Do not turn up the volume while listening to
a section with very low level inputs or no
audio signals. If you do, the speakers may be
damaged when a peak level section is played.
On cleaning
Clean the cabinet, panel, and controls with a
soft cloth slightly moistened with a mild
detergent solution. Do not use any type of
abrasive pad, scouring powder or solvent
such as alcohol or benzine.
Clean the cabinet, panel, and controls with a
soft cloth slightly moistened with a mild
detergent solution. Do not use any type of
abrasive pad, scouring powder or solvent
such as alcohol or benzine.
On cleaning discs, disc/lens cleaners
Do not use cleaning discs or disc/lens
cleaners (including wet or spray types).
These may cause the apparatus to
malfunction.
Do not use cleaning discs or disc/lens
cleaners (including wet or spray types).
These may cause the apparatus to
malfunction.
On replacement of parts
In the event that this unit is repaired, repaired
parts may be collected for reuse or recycling
purposes.
In the event that this unit is repaired, repaired
parts may be collected for reuse or recycling
purposes.
If you have any questions or problems
concerning your player, please consult your
nearest Sony dealer.
concerning your player, please consult your
nearest Sony dealer.
IMPORTANT NOTICE
Caution: This player is capable of holding a
still video image or on-screen display image
on your television screen indefinitely. If
you leave the still video image or on-screen
display image displayed on your TV for an
extended period of time you risk permanent
damage to your television screen. Plasma
display panel televisions and projection
televisions are susceptible to this.
Caution: This player is capable of holding a
still video image or on-screen display image
on your television screen indefinitely. If
you leave the still video image or on-screen
display image displayed on your TV for an
extended period of time you risk permanent
damage to your television screen. Plasma
display panel televisions and projection
televisions are susceptible to this.
SECTION 1
GENERAL
This section is extracted from instruction
manual. 3-283-149-61
manual. 3-283-149-61
1-2
DVP-NS601HP/NS700H/NS700HP/NS707HP/NS708H/NS708HP
7
Notes
• Notes about DVD+RWs/DVD+Rs/DVD+Rs
DL, DVD-RWs/DVD-Rs/DVD-Rs DL, or
CD-Rs/CD-RWs
Some DVD+RWs/DVD+Rs/DVD+Rs DL,
DVD-RWs/DVD-Rs/DVD-Rs DL, or CD-Rs/
CD-RWs cannot be played on this player due to
the recording quality or physical condition of the
disc, or the characteristics of the recording device
and authoring software.
The disc will not play if it has not been correctly
finalized. For more information, refer to the
operating instructions for the recording device.
Note that some playback functions may not work
with some DVD+RWs/DVD+Rs/DVD+Rs DL,
even if they have been correctly finalized. In this
case, view the disc by normal playback. Also
some DATA CDs/DATA DVDs created in Packet
Write format cannot be played.
CD-Rs/CD-RWs
Some DVD+RWs/DVD+Rs/DVD+Rs DL,
DVD-RWs/DVD-Rs/DVD-Rs DL, or CD-Rs/
CD-RWs cannot be played on this player due to
the recording quality or physical condition of the
disc, or the characteristics of the recording device
and authoring software.
The disc will not play if it has not been correctly
finalized. For more information, refer to the
operating instructions for the recording device.
Note that some playback functions may not work
with some DVD+RWs/DVD+Rs/DVD+Rs DL,
even if they have been correctly finalized. In this
case, view the disc by normal playback. Also
some DATA CDs/DATA DVDs created in Packet
Write format cannot be played.
• Music discs encoded with copyright protection
technologies
This product is designed to playback discs that
conform to the Compact Disc (CD) standard.
Recently, various music discs encoded with
copyright protection technologies are marketed
by some record companies. Please be aware that
among those discs, there are some that do not
conform to the CD standard and may not be
playable by this product.
This product is designed to playback discs that
conform to the Compact Disc (CD) standard.
Recently, various music discs encoded with
copyright protection technologies are marketed
by some record companies. Please be aware that
among those discs, there are some that do not
conform to the CD standard and may not be
playable by this product.
• For player that cannot play images that
contain a copy protection only
Images in DVD-VR mode with CPRM*
protection may not be played if they contain a
copy protection signal, “Copyright lock” appears
on the screen.
* CPRM (Content Protection for Recordable
Images in DVD-VR mode with CPRM*
protection may not be played if they contain a
copy protection signal, “Copyright lock” appears
on the screen.
* CPRM (Content Protection for Recordable
Media) is a coding technology that protects the
copyright of images.
copyright of images.
• Note on DualDiscs
A DualDisc is a two sided disc product which
mates DVD recorded material on one side with
digital audio material on the other side.
However, since the audio material side does not
conform to the Compact Disc (CD) standard,
playback on this product is not guaranteed.
mates DVD recorded material on one side with
digital audio material on the other side.
However, since the audio material side does not
conform to the Compact Disc (CD) standard,
playback on this product is not guaranteed.
Note on playback operations of
DVDs and VIDEO CDs
DVDs and VIDEO CDs
Some playback operations of DVDs and
VIDEO CDs may be intentionally set by
software producers. Since this player plays
DVDs and VIDEO CDs according to the disc
contents the software producers designed,
some playback features may not be available.
Also, refer to the instructions supplied with
the DVDs or VIDEO CDs.
VIDEO CDs may be intentionally set by
software producers. Since this player plays
DVDs and VIDEO CDs according to the disc
contents the software producers designed,
some playback features may not be available.
Also, refer to the instructions supplied with
the DVDs or VIDEO CDs.
Copyrights
This product incorporates copyright
protection technology that is protected by
U.S. patents and other intellectual property
rights. Use of this copyright protection
technology must be authorized by
Macrovision, and is intended for home and
other limited viewing uses only unless
otherwise authorized by Macrovision.
Reverse engineering or disassembly is
prohibited.
protection technology that is protected by
U.S. patents and other intellectual property
rights. Use of this copyright protection
technology must be authorized by
Macrovision, and is intended for home and
other limited viewing uses only unless
otherwise authorized by Macrovision.
Reverse engineering or disassembly is
prohibited.
8
Guide to Parts and Controls
For more information, see the pages indicated in parentheses.
Front panel
A [/1 (on/standby) button (24)
B Disc tray (24)
C Front panel display (9)
D (remote sensor) (20)
E HDMI* (High-Definition Multimedia
B Disc tray (24)
C Front panel display (9)
D (remote sensor) (20)
E HDMI* (High-Definition Multimedia
Interface) indicator (16, 62, 63)
Lights up when the HDMI OUT jack is
correctly connected to a HDCP (High-
bandwidth Digital Content Protection)
compliant device with HDMI or DVI
(Digital Visual Interface) input.
Lights up when the HDMI OUT jack is
correctly connected to a HDCP (High-
bandwidth Digital Content Protection)
compliant device with HDMI or DVI
(Digital Visual Interface) input.
F Z (open/close) button (24)
G N (play) button (24)
H x (stop) button (25)
G N (play) button (24)
H x (stop) button (25)
* This DVD player incorporates High-Definition
Multimedia Interface (HDMI™) technology.
“HDMI, the HDMI logo and High-Definition
Multimedia Interface are trademarks or registered
trademarks of HDMI Licensing LLC.”
Multimedia Interface are trademarks or registered
trademarks of HDMI Licensing LLC.”
Rear panel
A HDMI OUT (High-Definition
Multimedia Interface out) jack (15)
B DIGITAL OUT (OPTICAL) jack (18)
C DIGITAL OUT (COAXIAL) jack (18)
D LINE OUT L/R (AUDIO) jacks (18)
C DIGITAL OUT (COAXIAL) jack (18)
D LINE OUT L/R (AUDIO) jacks (18)
E LINE OUT (VIDEO) jack (15)
F S VIDEO OUT jack (15)
G COMPONENT VIDEO OUT jacks
F S VIDEO OUT jack (15)
G COMPONENT VIDEO OUT jacks
(15)
HDMI
9
Front panel display
When playing back a DVD
When playing back a VIDEO CD with Playback Control (PBC) (27)
When playing back a CD, DATA CD (MP3 audio/DivX video), DATA DVD (MP3 audio/DivX
video), or VIDEO CD (without PBC)
video), or VIDEO CD (without PBC)
* When playing DivX video files, the current track is not displayed.
Current title/chapter or playing time (27)
Lights up when you can change the angle (25)
Lights up during
Repeat Play (31)
Repeat Play (31)
Playing status
Current scene or playing time (27)
Playing status
Lights up during A-B Repeat Play (32)
Playing time (27)
Current track
*
(27)
Lights up during
Repeat Play (31)
Repeat Play (31)
Playing status
,continued
10
Remote
A TV [/1 (on/standby) button (21)
B Z OPEN/CLOSE button (25)
C Number buttons (27)
B Z OPEN/CLOSE button (25)
C Number buttons (27)
The number 5 button has a tactile dot.*
D CLEAR button (30)
E TOP MENU button (26)
F C/X/x/c buttons (25)
G O RETURN button (26)
H
E TOP MENU button (26)
F C/X/x/c buttons (25)
G O RETURN button (26)
H
/
REPLAY/STEP/
ADVANCE/STEP buttons (25, 40)
I ./> PREV/NEXT (previous/
next) buttons (25)
J
m/M
SCAN/SLOW
buttons (39)
K ZOOM button (25, 49)
L SLOW PLAY/FAST PLAY buttons
L SLOW PLAY/FAST PLAY buttons
(25)
M
/AUDIO button (43)
N
/SUBTITLE button (25, 49)
O [/1 (on/standby) button (24)
P 2/VOL (volume) +/– buttons (21)
P 2/VOL (volume) +/– buttons (21)
The + button has a tactile dot.*
Q t/TV/VIDEO button (21)
R PICTURE NAVI (picture navigation)
R PICTURE NAVI (picture navigation)
button (42, 48)
S TIME/TEXT button (27)
T MENU button (26)
U ENTER button (22)
V DISPLAY button (11)
W H/PLAY button (24)
T MENU button (26)
U ENTER button (22)
V DISPLAY button (11)
W H/PLAY button (24)
The
H button has a tactile dot.*
X x STOP button (25)
Y X PAUSE button (25)
Z SUR (surround) button (45)
wj
Y X PAUSE button (25)
Z SUR (surround) button (45)
wj
/ANGLE button (25)
* Use the tactile dot as a reference when operating
the player.
Click on the first or last page to see other DVP-NS601HP / DVP-NS700H / DVP-NS700HP / DVP-NS707HP / DVP-NS708H / DVP-NS708HP service manuals if exist.