LG WF-D8527DD Service Manual ▷ View online
9-5. Replace rotor and stator
②
②
remove rotor nuts with wrench(M18)。
②
remove and fetch out rotor as is shown.
Fixed hole
③
Remove fixed hole and Hydraulic
conductivity board。
conductivity board。
retaining piece
Stator base
Hall element
Hall element
④
Unplug hall element and stator connector
before removing stator.
before removing stator.
0
2
Circlip
⑤
Untighten six stator fixed screws
⑥
Check the direction of inner calandria
circlip.
circlip.
⑦
Tighten stator with handles and remove
the last screw.
the last screw.
Hallelement
Rtaining piece stator base
⑧
Pay attention to the wire statue in case of
noise.
noise.
9-6.Replace Clutch Components
①
Remove 9 fixed screws on clutch and fetch
out.
1
2
10. Troubleshooting
10-1.Check the problem against the list bellows
Symptom
Symptom
Error
Message
Check up
Check up
Water supply failure
● Is the water tap shut off?
● Is the water supply cut off？
● Is the water tap, water hose or inlet valve
clogged?
● Is the connector connected?
Drainage Failure
●Is the drain hose positioned correctly?
● Is the drain hose bent or placed too high?
● Is the internal part of the hose clogged?
Spin failure
● Is the laundry evenly balanced?
● Is the washing machine placed on a flat
surface?
● Is too much detergent used?
Door(Lid ) open
● Is the lid closed?
sensing
failure
Overflow failure
Motor limited Error
● see detailed information later
Clutching Error
2
2
10-2. Display troubleshooting according to errors
Problems Reasons
Possible causes
Solution measures
Water
supply
● Sensor null water level is under
26.0khz when watering for 12
minutes.
● Sensor the water level remains
unchanged every 5 minutes with
water supply above null water level.
● water tap is shut off
● water supply is cut off
●Inlet valve is clogged
● Connector is installed
improperly.
●Connection error of inlet
valve six-leg connector
and sub PC board.
● Turn on water tap
●Wait for water supply
● Clean or replace filter
● Connect connectors
properly
● As above
drainage
● Water does not drain within 12
minutes.
● Sensor water level is under 25.7khz for
6 times during SPIN with water.
● Is the drain hose
positioned correctly?
● Is the drain hose
clogged with impurities.
● Is the internal part of
positioned correctly?
● Is the drain hose
clogged with impurities.
● Is the internal part of
the hose clogged
● Height of drain hose
should be less than 6 cm
from the floor.
● Remove any foreign
objects inside pump.
● Replace the drain motor
should be less than 6 cm
from the floor.
● Remove any foreign
objects inside pump.
● Replace the drain motor
or connect connectors
properly.
properly.
Unbalance ● Three open circuits occur during
SPIN due to clothing placed
unevenly.
● laundry in the tub is
placed unevenly.
● The washer is placed on
an un-flat surface.
● Place the laundry
evenly
● Adjust Adjustable Legs
Door(Lid)
Open
● Lid is open during SPIN and WASH
● Continuous Alarm
● Lid is open during SPIN
Process.
● Lid is open during
WASH PROCESS
● Connection error of PC
board connectors.
● Close lid
● Close lid
●Connect
connectors
properly.
● Check over
3
2
Click on the first or last page to see other WF-D8527DD service manuals if exist.