JBL ON TOUR XTB (serv.man5) EMC - CB Certificate ▷ View online
Nemko USA, Inc.
11696 Sorrento Valley Rd., Suite F
San Diego, CA 92121-1024
Phone (858) 755-5525 Fax (858) 452-1810
Template 7-09aal
EMC
T
EST
R
EPORT
The
Bluetooth Portable Loudspeaker
Model: On Tour XTB
P
REPARED FOR
:
Harman Multimedia
8500 Balboa Blvd
Testing performed per the following:
R&TTE Directive
1999/5/EC
ETSI
EN
301
489-1
V1.8.1
(2008-04),
AND
ETSI
EN
301
489-17
V2.1.1
(2009-05)
P
REPARED ON
F
EBRUARY
18,
2010
R
EPORT
N
UMBER
:
2009
11138368
EMC
P
ROJECT
N
UMBER
:
12076-3
NEx Number
:
138368
Total Pages: 73
Nemko USA, Inc.
11696 Sorrento Valley Road, Suite F, San Diego, CA 92121
Phone (858) 755-5525 - Fax (858) 452-1810
DATE
DOCUMENT NAME
DOCUMENT #
PAGE
Error! Reference
source not
found.
Harman Multimedia - On Tour XTB - RTTE Test Report
2009 11138368 EMC
ii of 73
Template 7-09aal
DOCUMENT HISTORY
REVISION DATE
COMMENTS
-
February 18, 2010 Prepared By:
Alan Laudani
-
February 18, 2010 Initial Release: Chip
Fleury
NOTE: Nemko USA, Inc. hereby makes the following statements so as to conform to the Subclause 5.10
Requirements of ISO/IEC 17025 "General Criteria For the Competence Of Testing and Calibration
Laboratories":
o
The unit described in this report was received at Nemko USA, Inc.'s facilities on August 4,
2008.
o
Testing was performed on the unit described in this report on August 4, 2008 to November 30,
2009.
o
The Test Results reported herein apply only to the Unit actually tested, and to substantially
identical Units.
o
This report does not imply the endorsement of the Federal Communications Commission (FCC),
NVLAP or any other government agency.
This Report is the property of Nemko USA, Inc., and shall not be reproduced, except in full, without prior
written approval of Nemko USA, Inc. However, all ownership rights are hereby returned unconditionally to
Harman Multimedia, and approval is hereby granted to Harman Multimedia and its employees and agents to
reproduce all or part of this report for any legitimate business purpose without further reference to Nemko
USA, Inc.
Nemko USA, Inc.
11696 Sorrento Valley Road, Suite F, San Diego, CA 92121
Phone (858) 755-5525 - Fax (858) 452-1810
DATE
DOCUMENT NAME
DOCUMENT #
PAGE
Error! Reference
source not
found.
Harman Multimedia - On Tour XTB - RTTE Test Report
2009 11138368 EMC
iii of 73
Template 7-09aal
TABLE OF CONTENTS
DOCUMENT HISTORY ................................................................................................................................... ii
CERTIFICATION ............................................................................................................................................. v
1.
ADMINISTRATIVE DATA AND TEST SUMMARY ........................................................................... 4
1.1.
Administrative Data .................................................................................................................................. 4
1.2.
Test Summary ........................................................................................................................................... 6
2.
SYSTEM CONFIGURATION .................................................................................................................. 8
2.1.
System Components and Power Cables ................................................................................................... 8
2.2.
Device Interconnection and I/O Cables .................................................................................................... 8
2.3.
Description and Method of Exercising the EUT ...................................................................................... 8
2.4.
Design Modifications for Compliance ..................................................................................................... 9
3.
DESCRIPTION OF TEST SITE AND EQUIPMENT ......................................................................... 11
3.1.
Description of Test Site .......................................................................................................................... 11
4.
DESCRIPTION OF TESTING METHODS .......................................................................................... 11
4.1.
Introduction ............................................................................................................................................ 11
4.2.
Test Methods .......................................................................................................................................... 11
4.3.
Statistical Sampling Required for Continued Compliance ..................................................................... 13
4.4.
Configuration and Methods of Measurements for Conducted Emissions .............................................. 13
4.5.
Configuration and Methods of Measurements for Frequency Identification ......................................... 13
4.6.
Configuration and Methods of Measurements for Radiated Emissions ................................................. 15
4.7.
Power Line Harmonics: EN 61000-3-2: 2006 ........................................................................................ 17
4.8.
Power Line Fluctuations/Flicker: EN 61000-3-3: 2008 ......................................................................... 17
4.9.
Device Performance Criteria for Immunity Tests ................................................................................... 19
4.10.
Electrostatic Discharge Immunity: EN 61000-4-2: 2009 ................................................................... 21
4.11.
Radio Frequency Immunity: EN 61000-4-3: 2006 ............................................................................. 23
4.12.
Electrical Fast Transient Immunity: EN 61000-4-4: 2004 ................................................................. 25
4.13.
Power Line Surge Immunity: EN 61000-4-5: 2006 ........................................................................... 27
4.14.
Radio Frequency Conducted Common Mode Immunity: EN 61000-4-6 ........................................... 29
4.15.
Voltage Dips and Short Interruptions: EN 61000-4-11: 2004 ............................................................ 31
5.
TEST RESULTS ....................................................................................................................................... 33
5.1.
Conducted Emissions Test Data ............................................................................................................. 33
5.2.
Radiated Emissions Test Data ................................................................................................................ 35
5.3.
Power Line Harmonics Test Results ...................................................................................................... 37
5.4.
Power Line Fluctuations / Flicker Test Results ...................................................................................... 41
5.5.
Electrostatic Discharge Immunity Test Results & Test Points ............................................................... 44
5.6.
Radio Frequency Immunity Test Results ............................................................................................... 47
5.7.
Electrical Fast Transient Burst Immunity Test Results .......................................................................... 49
5.8.
Power Line Surge Immunity Test Results .............................................................................................. 50
5.9.
RF Conducted Common Mode Disturbance Immunity Test Results ..................................................... 52
5.10.
Voltage Dips and Interruptions Immunity Test Results ..................................................................... 53
Nemko USA, Inc.
11696 Sorrento Valley Road, Suite F, San Diego, CA 92121
Phone (858) 755-5525 - Fax (858) 452-1810
DATE
DOCUMENT NAME
DOCUMENT #
PAGE
Error! Reference
source not
found.
Harman Multimedia - On Tour XTB - RTTE Test Report
2009 11138368 EMC
iv of 73
Template 7-09aal
TEST SETUP DIAGRAMS
Figure 1. Frequency ID of Radiated Emissions Test Setup Diagram ............................................................... 14
Figure 1. Frequency ID of Radiated Emissions Test Setup Diagram ............................................................... 14
Figure 2. Radiated Emissions Test Setup Diagram .......................................................................................... 16
Figure 3. Harmonics & Flicker Test Setup Diagram ........................................................................................ 18
Figure 4. ESD Test Setup Diagram .................................................................................................................. 22
Figure 5. Radio Frequency Immunity Test Setup Diagram .............................................................................. 24
Figure 6. EFT Immunity Test Setup Diagram .................................................................................................. 26
Figure 7. Power Line Surge Immunity Test Setup Diagram ............................................................................ 28
Figure 8. RF Common Mode Immunity Test Setup Diagram .......................................................................... 30
Figure 9. Voltage Dips and Short Interruptions Test Setup Diagram .............................................................. 32
Figure 10. ESD Test Points .............................................................................................................................. 45
TEST CONFIGURATION PHOTOGRAPHS
Photograph 1. EUT Top and Bottom ................................................................................................................ 10
Photograph 1. EUT Top and Bottom ................................................................................................................ 10
Photograph 2. General Test Configuration ....................................................................................................... 12
Photograph 3. Conducted Emissions Test Configuration ................................................................................. 54
Photograph 3. Radiated Emissions Test Configuration ................................................................................... 55
Photograph 5. Power line Harmonics and Flicker Test Configuration ............................................................. 56
Photograph 6. ESD Test Configuration ............................................................................................................ 57
Photograph 7. Radio Frequency Immunity Test Configuration ....................................................................... 58
Photograph 8. EFT Immunity Test Configuration ............................................................................................ 59
Photograph 9. Power Line Surge Immunity Test Configuration ...................................................................... 60
Photograph 10. RF Common Mode Immunity Test Configuration .................................................................. 61
Photograph 11. Voltage Dips/Short Interruptions Test Configuration ............................................................. 62
APPENDICES
A. Radiated Emissions Measurement Uncertainties ........................................................................................ A1
A. Radiated Emissions Measurement Uncertainties ........................................................................................ A1
B. Nemko USA, Inc. Test Equipment & Facilities Calibration Program ......................................................... B1
C. NVLAP Accrediation .................................................................................................................................. C1
D. Nemko Authorization ................................................................................................................................. D1